Repair and Diagnosis (Single Page)
You are viewing the full "tree" of links on one page. This can load slowly, but is easier to search. The same page can appear multiple times under a different folder, that is why the page is so large.View "split tree" where inner folders are split out. where inner links are on separate pages.
Quick Lookups- Common Specs & Procedures - Coupe
- DTC Index - Coupe
Electrical Component Locations
Fluids
Technical Bulletins
Tire Fitment
Wiring Diagrams- System Wiring Diagrams - 2D Coupe
- Air Conditioning
- Anti-Lock Brakes
- Anti-Theft
- Body Computer
- Computer Data Lines
- Cooling Fan
- Cruise Control
- Defoggers
- Engine Performance
- Exterior Lights
- Ground Distribution
- Headlights
- Horn
- Instrument Cluster
- Interior Lights
- Power Distribution
- Power Door Locks
- Power Mirrors
- Power Seats
- Power Top/Sunroof
- Power Windows
- Radio
- Starting/Charging
- Supplemental Restraints
- Transmission
- Warning Systems
- Wiper/Washer
- Using lemon2025'S System Wiring Diagrams
- System Wiring Diagrams - 2D Coupe
- Accessories & Equipment
- Anti-Theft Systems
- Anti-Theft Systems - Coupe
- Power Door Locks - Coupe
- Description
- Operation
- Component Locations
- Programming
- Adjustments
- Symptom Tests
- Notes
- Test No. 1: Central Door Locking System Does Not Operate Properly
- Test No. 2: Some Doors Do Not Lock Or Unlock
- Test No. 3: All Doors Do Not Lock Or Unlock Using Door Lock Switch
- Test No. 4: All Doors Do Not Lock Or Unlock Using Door Lock Key
- Test No. 5: All Doors Do Not Lock Or Unlock Using Driver's Inside Manual Lock Knob
- Test No. 6: Forgotten Key Prevention Function Inoperative
- Test No. 7: Rolling Lock Function Inoperative
- Component Tests
- Removal & Installation
- Wiring Diagrams
- Remote Keyless Entry System - Coupe
- Description & Operation
- Component Locations
- Programming
- Symptom Tests
- Notes
- Test No. 1: Remote Keyless Entry System Inoperative
- Test No. 2: Lights Do Not Flash When Using Remote Keyless Entry System
- Test No. 3: Remote Trunk Lid Release Function Inoperative
- Test No. 4: Encrypted Code Cannot Be Registered
- Test 5: Hazard Warning Lights Do Not Flash When Switch Is Turned On
- Test 6: Turn Signal Light Does Not Flash When Switch Is Turned On
- Test 7: Hazard Warning Light Switch Signal Is Not Sent To ETACS-Ecu
- Test 8: Interior Light Dimming Function Does Not Work Normally
- Test 9: Horn Does Not Sound When Anti-Theft Alarm Is Triggered
- Removal & Installation
- Wiring Diagrams
- Body Interior
- Body Control Modules - Coupe
- Description
- Operation
- Component Locations
- Trouble Shooting
- Self-Diagnostic System
- Diagnostic Tests
- System Tests
- Check ETACS Ecu Power Supply Circuit From Battery
- Ecu Terminal Check
- Input Signal Check
- Notes
- Using Scan Tool
- Using Analog Voltmeter
- Test No. 1: Ignition Switch (ACC) Signal Is Not Sent To ETACS ECU
- Test No. 2: Ignition Switch (IG1) Signal Is Not Sent To ETACS ECU
- Test No. 3: Key-In-Ignition Reminder Switch Signal Is Not Sent To ETACS ECU
- Test No. 4: Hazard Warning Light Switch Signal Is Not Sent To ETACS ECU
- Test No. 5: Foglight Switch Signal Is Not Sent To ETACS ECU
- Test No. 6: Washer Fluid Level Switch Signal Is Not Sent To ETACS ECU
- Test No. 7: Driver's Seat Belt Switch Signal Is Not Sent To ETACS ECU
- Test No. 8: Door Ajar Switch Signal Is Not Sent To ETACS ECU
- Test No. 9: Door Key Switch Signal Is Not Sent To ETACS ECU
- Test No. 10: Door Lock Actuator Switch Signal Is Not Sent To ETACS ECU
- Test No. 11: Door Lock Master Switch Signal Is Not Sent To ETACS ECU
- Test No. 12: Trunk Lid Latch Switch Signal Is Not Sent To ETACS ECU
- Test No. 13: Trunk Lid Key Switch Signal Is Not Sent To ETACS ECU
- Test No. 14: Vehicle Speed Signal Is Not Sent To ETACS ECU
- Test No. 15: Taillight, Headlight, Passing, Turn Signal Or Dimmer Switch Signal Is Not Sent To ETACS ECU
- Test No. 16: Windshield Mist, Intermittent, Low Speed, High Speed Or Washer Switch Signal Is Not Sent To ETACS ECU
- Test No. 17: Windshield Intermittent Position Switch Signal Is Not Sent To ETACS ECU
- Test No. 18: Remote Keyless Entry System Transmitter Signal Is Not Sent To ETACS ECU
- Test No. 19: Sun Roof Switch Signal Is Not Sent To ETACS ECU
- Scan Tool Communication With Any System Not Possible
- Scan Tool Communication With ETACS Ecu Not Possible
- Symptom Tests
- Notes
- Tone Alarm
- Test No. 1: Ignition Key Reminder Tone Alarm Function Does Not Operate Properly
- Test No. 2: Light Reminder Tone Alarm Function Does Not Operate Properly
- Test No. 3: Door Ajar Tone Alarm Function Does Not Operate Properly
- Test No. 4: Low Washer Fluid Tone Alarm Function Does Not Operate Properly
- Test No. 5: Seat Belt Tone Alarm Function Does Not Operate Properly
- Test No. 6: Low Fuel Level Alarm Function Does Not Operate Properly
- Exterior/Interior Lights
- Test No. 7: Taillights Inoperative
- Test No. 8: Low Beam Headlights Inoperative
- Test No. 9: High Beam Headlights Inoperative
- Test No. 10: Headlights Inoperative With Passing Switch
- Test No. 11: Headlight Automatic Shutdown Function Inoperative
- Test No. 12: Headlight Dimmer Switch Reset Function Inoperative
- Test No. 13: High Beam Indicator Inoperative
- Test No. 14: Turn Signals Inoperative
- Test No. 15: Hazard Lights Inoperative
- Test No. 16: Foglights Inoperative
- Test No. 17: Foglights Do Not Turn Off When Headlights Are Turned Off
- Test No. 18: Interior Lights Do Not Operate Properly
- Component Tests
- Removal & Installation
- Wiring Diagrams
- Body Control Modules - Coupe
- Communication Devices
- Body Control Modules - Coupe
- Description
- Operation
- Component Locations
- Trouble Shooting
- Self-Diagnostic System
- Diagnostic Tests
- System Tests
- Check ETACS Ecu Power Supply Circuit From Battery
- Ecu Terminal Check
- Input Signal Check
- Notes
- Using Scan Tool
- Using Analog Voltmeter
- Test No. 1: Ignition Switch (ACC) Signal Is Not Sent To ETACS ECU
- Test No. 2: Ignition Switch (IG1) Signal Is Not Sent To ETACS ECU
- Test No. 3: Key-In-Ignition Reminder Switch Signal Is Not Sent To ETACS ECU
- Test No. 4: Hazard Warning Light Switch Signal Is Not Sent To ETACS ECU
- Test No. 5: Foglight Switch Signal Is Not Sent To ETACS ECU
- Test No. 6: Washer Fluid Level Switch Signal Is Not Sent To ETACS ECU
- Test No. 7: Driver's Seat Belt Switch Signal Is Not Sent To ETACS ECU
- Test No. 8: Door Ajar Switch Signal Is Not Sent To ETACS ECU
- Test No. 9: Door Key Switch Signal Is Not Sent To ETACS ECU
- Test No. 10: Door Lock Actuator Switch Signal Is Not Sent To ETACS ECU
- Test No. 11: Door Lock Master Switch Signal Is Not Sent To ETACS ECU
- Test No. 12: Trunk Lid Latch Switch Signal Is Not Sent To ETACS ECU
- Test No. 13: Trunk Lid Key Switch Signal Is Not Sent To ETACS ECU
- Test No. 14: Vehicle Speed Signal Is Not Sent To ETACS ECU
- Test No. 15: Taillight, Headlight, Passing, Turn Signal Or Dimmer Switch Signal Is Not Sent To ETACS ECU
- Test No. 16: Windshield Mist, Intermittent, Low Speed, High Speed Or Washer Switch Signal Is Not Sent To ETACS ECU
- Test No. 17: Windshield Intermittent Position Switch Signal Is Not Sent To ETACS ECU
- Test No. 18: Remote Keyless Entry System Transmitter Signal Is Not Sent To ETACS ECU
- Test No. 19: Sun Roof Switch Signal Is Not Sent To ETACS ECU
- Scan Tool Communication With Any System Not Possible
- Scan Tool Communication With ETACS Ecu Not Possible
- Symptom Tests
- Notes
- Tone Alarm
- Test No. 1: Ignition Key Reminder Tone Alarm Function Does Not Operate Properly
- Test No. 2: Light Reminder Tone Alarm Function Does Not Operate Properly
- Test No. 3: Door Ajar Tone Alarm Function Does Not Operate Properly
- Test No. 4: Low Washer Fluid Tone Alarm Function Does Not Operate Properly
- Test No. 5: Seat Belt Tone Alarm Function Does Not Operate Properly
- Test No. 6: Low Fuel Level Alarm Function Does Not Operate Properly
- Exterior/Interior Lights
- Test No. 7: Taillights Inoperative
- Test No. 8: Low Beam Headlights Inoperative
- Test No. 9: High Beam Headlights Inoperative
- Test No. 10: Headlights Inoperative With Passing Switch
- Test No. 11: Headlight Automatic Shutdown Function Inoperative
- Test No. 12: Headlight Dimmer Switch Reset Function Inoperative
- Test No. 13: High Beam Indicator Inoperative
- Test No. 14: Turn Signals Inoperative
- Test No. 15: Hazard Lights Inoperative
- Test No. 16: Foglights Inoperative
- Test No. 17: Foglights Do Not Turn Off When Headlights Are Turned Off
- Test No. 18: Interior Lights Do Not Operate Properly
- Component Tests
- Removal & Installation
- Wiring Diagrams
- Body Control Modules - Coupe
- Cruise Control Systems - Coupe
- Description
- Operation
- Component Locations
- Trouble Shooting
- Self-Diagnostic System
- Diagnostic Tests
- System Tests
- Symptom Tests
- Notes
- Test No. 1: Cruise Control Does Not Cancel When Brake Pedal Is Depressed
- Test No. 2: Cruise Control Does Not Cancel When Clutch Pedal Is Depressed
- Test No. 3: Cruise Control Does Not Cancel When Gear Selector Is Moved To "N" Position
- Test No. 4: Cruise Control Does Not Cancel When Cancel Switch Is Pulled
- Test No. 5: Cruise Control Cannot Be Set
- Test No. 6: Cruise Control Hunts At Set Speed
- Test No. 7: Cruise Control Indicator Inoperative
- Component Tests
- Removal & Installation
- Wiring Diagrams
- Entertainment Systems
- Audio System - Coupe
- Radio And Tape Player
- Radio With Tape Player And Cd Player, Speaker And Antenna Diagnosis
- Symptom Procedures
- Notes
- INSPECTION PROCEDURE 1: When Power Switch Is Turned "ON," No Power Is Available
- INSPECTION PROCEDURE 2: No Sound < Vehicles With Amplifier >
- INSPECTION PROCEDURE 3: No Sound From One Speaker
- INSPECTION PROCEDURE 4: Noise Appears At Certain Places When Traveling (AM)
- INSPECTION PROCEDURE 5: Noise Appears At Certain Places When Traveling (FM)
- INSPECTION PROCEDURE 6: Mixed With Noise, Only At Right (AM)
- INSPECTION PROCEDURE 7: Broadcasts Can Be Heard But Both AM And FM Have A Lot Of Noise
- INSPECTION PROCEDURE 8: There Is More Noise On Either AM Or FM
- INSPECTION PROCEDURE 9: There Is Noise When Starting The Engine
- INSPECTION PROCEDURE 10: Some Noise Appears When There Is Vibration Or Shocks During Traveling.
- INSPECTION PROCEDURE 11: Noise Sometimes Appears On FM During Traveling.
- INSPECTION PROCEDURE 12: Ever-Present Noise
- INSPECTION PROCEDURE 13: There Is Noise But No Reception For Both AM And FM Or No Sound From AM, Or No Sound From FM
- INSPECTION PROCEDURE 14: Poor Reception
- INSPECTION PROCEDURE 15: Distortion On AM Or On Both AM And FM
- INSPECTION PROCEDURE 16: Distortion On FM Only
- INSPECTION PROCEDURE 17: Using The Auto Select Function, Too Few Automatic Stations Are Selected
- INSPECTION PROCEDURE 18: Preset Stations Are Erased
- INSPECTION PROCEDURE 19: Cassette Tape Can Not Be Inserted
- INSPECTION PROCEDURE 20: Sound Quality Is Poor, Or Sound Is Weak
- INSPECTION PROCEDURE 21: Cassette Tape Can Not Be Ejected
- INSPECTION PROCEDURE 22: Uneven Revolution, Tape Speed Is Fast Or Slow
- INSPECTION PROCEDURE 23: Automatic Search Does Not Work
- INSPECTION PROCEDURE 24: Malfunction Of The Auto Reverse
- INSPECTION PROCEDURE 25: Tape Gets Caught In Mechanism
- INSPECTION PROCEDURE 26: CD Can Not Be Inserted
- INSPECTION PROCEDURE 27: No Sound (CD Only)
- INSPECTION PROCEDURE 28: CD Sound Skips
- INSPECTION PROCEDURE 29: Sound Quality Is Poor
- INSPECTION PROCEDURE 30: CD Can Not Be Ejected
- Special Tools
- Radio With Tape Player And Cd Player
- Speaker
- Amplifier
- Antenna
- Specifications
- Radio And Tape Player
- Audio System - Coupe
- Exterior Lights
- Lighting Systems
- Headlight And Front Side Marker Light Assembly
- Fog Light And Front Turn Signal Light < SEBRING >
- Fog Light < Stratus >
- Rear Combination Light
- Dome Light
- High-Mounted Stoplight
- Backup Light
- Specifications
- Lighting Systems - Turn Signal And Hazard Warning Systems
- Lighting Systems
- Gauges & Instrument Panels
- Analog Instrument Panels - Coupe
- Description & Operation
- Component Locations
- Programming
- System Tests
- Notes
- Test No. 1: Coolant Temperature Gauge Inoperative
- Test No. 2: Door Ajar Warning Indicator Does Not Operate Properly
- Test No. 3: Fuel Gauge Inoperative
- Test No. 4: Seat Belt Warning Indicator Does Not Operate Properly
- Test No. 5: Speedometer Inoperative
- Test No. 6: Tachometer Inoperative
- Test No. 7: Screen Is Blank
- Test No. 8: Compass Is Not Displayed
- Test No. 9: Compass Is Incorrect
- Test No. 10: Outside Temperature Displays E0°F Or -E5°F
- Test No. 11: Outside Temperature & Compass Do Not Change
- Component Tests
- Removal & Installation
- Wiring Diagrams
- Analog Instrument Panels - Coupe
- Heated Glass/Defoggers
- Infotainment
- Audio System - Coupe
- Radio And Tape Player
- Radio With Tape Player And Cd Player, Speaker And Antenna Diagnosis
- Symptom Procedures
- Notes
- INSPECTION PROCEDURE 1: When Power Switch Is Turned "ON," No Power Is Available
- INSPECTION PROCEDURE 2: No Sound < Vehicles With Amplifier >
- INSPECTION PROCEDURE 3: No Sound From One Speaker
- INSPECTION PROCEDURE 4: Noise Appears At Certain Places When Traveling (AM)
- INSPECTION PROCEDURE 5: Noise Appears At Certain Places When Traveling (FM)
- INSPECTION PROCEDURE 6: Mixed With Noise, Only At Right (AM)
- INSPECTION PROCEDURE 7: Broadcasts Can Be Heard But Both AM And FM Have A Lot Of Noise
- INSPECTION PROCEDURE 8: There Is More Noise On Either AM Or FM
- INSPECTION PROCEDURE 9: There Is Noise When Starting The Engine
- INSPECTION PROCEDURE 10: Some Noise Appears When There Is Vibration Or Shocks During Traveling.
- INSPECTION PROCEDURE 11: Noise Sometimes Appears On FM During Traveling.
- INSPECTION PROCEDURE 12: Ever-Present Noise
- INSPECTION PROCEDURE 13: There Is Noise But No Reception For Both AM And FM Or No Sound From AM, Or No Sound From FM
- INSPECTION PROCEDURE 14: Poor Reception
- INSPECTION PROCEDURE 15: Distortion On AM Or On Both AM And FM
- INSPECTION PROCEDURE 16: Distortion On FM Only
- INSPECTION PROCEDURE 17: Using The Auto Select Function, Too Few Automatic Stations Are Selected
- INSPECTION PROCEDURE 18: Preset Stations Are Erased
- INSPECTION PROCEDURE 19: Cassette Tape Can Not Be Inserted
- INSPECTION PROCEDURE 20: Sound Quality Is Poor, Or Sound Is Weak
- INSPECTION PROCEDURE 21: Cassette Tape Can Not Be Ejected
- INSPECTION PROCEDURE 22: Uneven Revolution, Tape Speed Is Fast Or Slow
- INSPECTION PROCEDURE 23: Automatic Search Does Not Work
- INSPECTION PROCEDURE 24: Malfunction Of The Auto Reverse
- INSPECTION PROCEDURE 25: Tape Gets Caught In Mechanism
- INSPECTION PROCEDURE 26: CD Can Not Be Inserted
- INSPECTION PROCEDURE 27: No Sound (CD Only)
- INSPECTION PROCEDURE 28: CD Sound Skips
- INSPECTION PROCEDURE 29: Sound Quality Is Poor
- INSPECTION PROCEDURE 30: CD Can Not Be Ejected
- Special Tools
- Radio With Tape Player And Cd Player
- Speaker
- Amplifier
- Antenna
- Specifications
- Radio And Tape Player
- Audio System - Coupe
- Power Mirrors - Coupe
- Seats
- Steering Column Switches - Coupe
- Window Motors & Regulators
- Power Windows - Coupe
- Description & Operation
- Component Locations
- Adjustments
- System Tests
- Notes
- Test No. 1: Power Windows Inoperative
- Test No. 2: Power Window Timer Function Does Not Work Normally
- Test No. 3: Only Driver's Power Window Does Not Work By Operating Power Window Main Switch
- Test No. 4: Power Window Does Not Work Normally By Operating Passenger's Power Window Sub Switch
- Test No. 5: Passenger's Window Do Not Work Normally By Operating Power Window Main Switch
- Component Tests
- Removal & Installation
- Wiring Diagrams
- Power Windows - Coupe
- Wiper/Washer Systems
- Anti-Theft Systems
- Body & Frame
- Body, Cab Control Systems
- Body Control Modules - Coupe
- Description
- Operation
- Component Locations
- Trouble Shooting
- Self-Diagnostic System
- Diagnostic Tests
- System Tests
- Check ETACS Ecu Power Supply Circuit From Battery
- Ecu Terminal Check
- Input Signal Check
- Notes
- Using Scan Tool
- Using Analog Voltmeter
- Test No. 1: Ignition Switch (ACC) Signal Is Not Sent To ETACS ECU
- Test No. 2: Ignition Switch (IG1) Signal Is Not Sent To ETACS ECU
- Test No. 3: Key-In-Ignition Reminder Switch Signal Is Not Sent To ETACS ECU
- Test No. 4: Hazard Warning Light Switch Signal Is Not Sent To ETACS ECU
- Test No. 5: Foglight Switch Signal Is Not Sent To ETACS ECU
- Test No. 6: Washer Fluid Level Switch Signal Is Not Sent To ETACS ECU
- Test No. 7: Driver's Seat Belt Switch Signal Is Not Sent To ETACS ECU
- Test No. 8: Door Ajar Switch Signal Is Not Sent To ETACS ECU
- Test No. 9: Door Key Switch Signal Is Not Sent To ETACS ECU
- Test No. 10: Door Lock Actuator Switch Signal Is Not Sent To ETACS ECU
- Test No. 11: Door Lock Master Switch Signal Is Not Sent To ETACS ECU
- Test No. 12: Trunk Lid Latch Switch Signal Is Not Sent To ETACS ECU
- Test No. 13: Trunk Lid Key Switch Signal Is Not Sent To ETACS ECU
- Test No. 14: Vehicle Speed Signal Is Not Sent To ETACS ECU
- Test No. 15: Taillight, Headlight, Passing, Turn Signal Or Dimmer Switch Signal Is Not Sent To ETACS ECU
- Test No. 16: Windshield Mist, Intermittent, Low Speed, High Speed Or Washer Switch Signal Is Not Sent To ETACS ECU
- Test No. 17: Windshield Intermittent Position Switch Signal Is Not Sent To ETACS ECU
- Test No. 18: Remote Keyless Entry System Transmitter Signal Is Not Sent To ETACS ECU
- Test No. 19: Sun Roof Switch Signal Is Not Sent To ETACS ECU
- Scan Tool Communication With Any System Not Possible
- Scan Tool Communication With ETACS Ecu Not Possible
- Symptom Tests
- Notes
- Tone Alarm
- Test No. 1: Ignition Key Reminder Tone Alarm Function Does Not Operate Properly
- Test No. 2: Light Reminder Tone Alarm Function Does Not Operate Properly
- Test No. 3: Door Ajar Tone Alarm Function Does Not Operate Properly
- Test No. 4: Low Washer Fluid Tone Alarm Function Does Not Operate Properly
- Test No. 5: Seat Belt Tone Alarm Function Does Not Operate Properly
- Test No. 6: Low Fuel Level Alarm Function Does Not Operate Properly
- Exterior/Interior Lights
- Test No. 7: Taillights Inoperative
- Test No. 8: Low Beam Headlights Inoperative
- Test No. 9: High Beam Headlights Inoperative
- Test No. 10: Headlights Inoperative With Passing Switch
- Test No. 11: Headlight Automatic Shutdown Function Inoperative
- Test No. 12: Headlight Dimmer Switch Reset Function Inoperative
- Test No. 13: High Beam Indicator Inoperative
- Test No. 14: Turn Signals Inoperative
- Test No. 15: Hazard Lights Inoperative
- Test No. 16: Foglights Inoperative
- Test No. 17: Foglights Do Not Turn Off When Headlights Are Turned Off
- Test No. 18: Interior Lights Do Not Operate Properly
- Component Tests
- Removal & Installation
- Wiring Diagrams
- Body Control Modules - Coupe
- Door Locks
- Anti-Theft Systems - Coupe
- Power Door Locks - Coupe
- Description
- Operation
- Component Locations
- Programming
- Adjustments
- Symptom Tests
- Notes
- Test No. 1: Central Door Locking System Does Not Operate Properly
- Test No. 2: Some Doors Do Not Lock Or Unlock
- Test No. 3: All Doors Do Not Lock Or Unlock Using Door Lock Switch
- Test No. 4: All Doors Do Not Lock Or Unlock Using Door Lock Key
- Test No. 5: All Doors Do Not Lock Or Unlock Using Driver's Inside Manual Lock Knob
- Test No. 6: Forgotten Key Prevention Function Inoperative
- Test No. 7: Rolling Lock Function Inoperative
- Component Tests
- Removal & Installation
- Wiring Diagrams
- Remote Keyless Entry System - Coupe
- Description & Operation
- Component Locations
- Programming
- Symptom Tests
- Notes
- Test No. 1: Remote Keyless Entry System Inoperative
- Test No. 2: Lights Do Not Flash When Using Remote Keyless Entry System
- Test No. 3: Remote Trunk Lid Release Function Inoperative
- Test No. 4: Encrypted Code Cannot Be Registered
- Test 5: Hazard Warning Lights Do Not Flash When Switch Is Turned On
- Test 6: Turn Signal Light Does Not Flash When Switch Is Turned On
- Test 7: Hazard Warning Light Switch Signal Is Not Sent To ETACS-Ecu
- Test 8: Interior Light Dimming Function Does Not Work Normally
- Test 9: Horn Does Not Sound When Anti-Theft Alarm Is Triggered
- Removal & Installation
- Wiring Diagrams
- Power Mirrors - Coupe
- Seats
- Sun Roof/T-Top/Convertible Top
- Power Windows - Coupe
- Description & Operation
- Component Locations
- Adjustments
- System Tests
- Notes
- Test No. 1: Power Windows Inoperative
- Test No. 2: Power Window Timer Function Does Not Work Normally
- Test No. 3: Only Driver's Power Window Does Not Work By Operating Power Window Main Switch
- Test No. 4: Power Window Does Not Work Normally By Operating Passenger's Power Window Sub Switch
- Test No. 5: Passenger's Window Do Not Work Normally By Operating Power Window Main Switch
- Component Tests
- Removal & Installation
- Wiring Diagrams
- Body, Cab Control Systems
- Brakes
- Anti-Lock Brakes
- Anti-Lock Brake System - Coupe
- General Description
- Anti-Lock Braking System (Abs) Diagnosis
- Introduction To Anti-Lock Brake System Diagnosis
- Abs Diagnostic Troubleshooting Strategy
- Abs Trouble Code Diagnosis
- Diagnostic Trouble Code Chart
- Diagnostic Trouble Code Procedures
- DTC 11,12,13,14: Wheel Speed Sensor (Open Circuit Or Short Circuit), DTC 21, 22, 23, 24: Wheel Speed Sensor
- DTC 15: Wheel Speed Sensor (Abnormal Output Signal)
- DTC 38: Stoplight Switch System
- DTC 41, 42, 43, 44, 45, 46, 47, 48: ABS Solenoid Valve Inside Hydraulic Unit (Open Circuit Or Short Circuit), DTC 51: Valve Power Supply, DTC 53: Pump Motor
- Symptom Chart
- Symptom Procedures
- INSPECTION PROCEDURE 1: Communication Between The Scan Tool And The ABS-ECU Is Not Possible.
- INSPECTION PROCEDURE 2: The ABS Warning Light does Not Illuminate, When The Ignition Key Is Turned To "On." (Engine Stopped Or After Start-up)
- INSPECTION PROCEDURE 3: The ABS Warning Light Remains Illuminated After the Engine is Started.
- Data List Reference Table
- Actuator Test Reference Table
- Check At Abs-Ecu
- Special Tools
- On-Vehicle Service
- Master Cylinder And Brake Booster
- Hydraulic Unit
- Wheel Speed Sensor
- Specifications
- Traction Control Systems - Coupe
- General Description
- Traction Control System (TCL) Diagnosis
- TCL Diagnostic Trouble Code Detection Conditions
- TCL Diagnostic Troubleshooting Strategy
- TCL Trouble Code Diagnosis
- Diagnostic Trouble Code Chart
- Diagnostic Trouble Code Procedures
- Symptom Chart
- Symptom Procedures
- INSPECTION PROCEDURE 1: When the Ignition Switch is Turned to "ON" (Engine Stopped or After Startup), the TCL Indicator Light does not Illuminate.
- INSPECTION PROCEDURE 2: When the Ignition Switch is Turned to "ON" (Engine Stopped or After Start-up), the TCL Warning Light does not Illuminate
- INSPECTION PROCEDURE 3: The TCL Indicator Light Remains Illuminated After the Engine is Started.
- INSPECTION PROCEDURE 4: The TCL Warning Light Remains Illuminated After the Engine is Started.
- INSPECTION PROCEDURE 5: The TCL System does not Operate.
- Data List Reference Table
- Actuator Test Reference Table
- Check At Abs-Ecu
- Special Tools
- On-Vehicle Service
- Anti-Lock Brake System - Coupe
- Mechanical - Hydraulic
- Traction Control
- Anti-Lock Brake System - Coupe
- General Description
- Anti-Lock Braking System (Abs) Diagnosis
- Introduction To Anti-Lock Brake System Diagnosis
- Abs Diagnostic Troubleshooting Strategy
- Abs Trouble Code Diagnosis
- Diagnostic Trouble Code Chart
- Diagnostic Trouble Code Procedures
- DTC 11,12,13,14: Wheel Speed Sensor (Open Circuit Or Short Circuit), DTC 21, 22, 23, 24: Wheel Speed Sensor
- DTC 15: Wheel Speed Sensor (Abnormal Output Signal)
- DTC 38: Stoplight Switch System
- DTC 41, 42, 43, 44, 45, 46, 47, 48: ABS Solenoid Valve Inside Hydraulic Unit (Open Circuit Or Short Circuit), DTC 51: Valve Power Supply, DTC 53: Pump Motor
- Symptom Chart
- Symptom Procedures
- INSPECTION PROCEDURE 1: Communication Between The Scan Tool And The ABS-ECU Is Not Possible.
- INSPECTION PROCEDURE 2: The ABS Warning Light does Not Illuminate, When The Ignition Key Is Turned To "On." (Engine Stopped Or After Start-up)
- INSPECTION PROCEDURE 3: The ABS Warning Light Remains Illuminated After the Engine is Started.
- Data List Reference Table
- Actuator Test Reference Table
- Check At Abs-Ecu
- Special Tools
- On-Vehicle Service
- Master Cylinder And Brake Booster
- Hydraulic Unit
- Wheel Speed Sensor
- Specifications
- Traction Control Systems - Coupe
- General Description
- Traction Control System (TCL) Diagnosis
- TCL Diagnostic Trouble Code Detection Conditions
- TCL Diagnostic Troubleshooting Strategy
- TCL Trouble Code Diagnosis
- Diagnostic Trouble Code Chart
- Diagnostic Trouble Code Procedures
- Symptom Chart
- Symptom Procedures
- INSPECTION PROCEDURE 1: When the Ignition Switch is Turned to "ON" (Engine Stopped or After Startup), the TCL Indicator Light does not Illuminate.
- INSPECTION PROCEDURE 2: When the Ignition Switch is Turned to "ON" (Engine Stopped or After Start-up), the TCL Warning Light does not Illuminate
- INSPECTION PROCEDURE 3: The TCL Indicator Light Remains Illuminated After the Engine is Started.
- INSPECTION PROCEDURE 4: The TCL Warning Light Remains Illuminated After the Engine is Started.
- INSPECTION PROCEDURE 5: The TCL System does not Operate.
- Data List Reference Table
- Actuator Test Reference Table
- Check At Abs-Ecu
- Special Tools
- On-Vehicle Service
- Anti-Lock Brake System - Coupe
- Anti-Lock Brakes
- Drivelines & Axles
- Electrical
- Charging Systems
- Component Locations
- Fuses & Circuit Breakers - Coupe
- Gauges
- Analog Instrument Panels - Coupe
- Description & Operation
- Component Locations
- Programming
- System Tests
- Notes
- Test No. 1: Coolant Temperature Gauge Inoperative
- Test No. 2: Door Ajar Warning Indicator Does Not Operate Properly
- Test No. 3: Fuel Gauge Inoperative
- Test No. 4: Seat Belt Warning Indicator Does Not Operate Properly
- Test No. 5: Speedometer Inoperative
- Test No. 6: Tachometer Inoperative
- Test No. 7: Screen Is Blank
- Test No. 8: Compass Is Not Displayed
- Test No. 9: Compass Is Incorrect
- Test No. 10: Outside Temperature Displays E0°F Or -E5°F
- Test No. 11: Outside Temperature & Compass Do Not Change
- Component Tests
- Removal & Installation
- Wiring Diagrams
- Analog Instrument Panels - Coupe
- Starter
- Wiring Diagrams
- System Wiring Diagrams - 2D Coupe
- Air Conditioning
- Anti-Lock Brakes
- Anti-Theft
- Body Computer
- Computer Data Lines
- Cooling Fan
- Cruise Control
- Defoggers
- Engine Performance
- Exterior Lights
- Ground Distribution
- Headlights
- Horn
- Instrument Cluster
- Interior Lights
- Power Distribution
- Power Door Locks
- Power Mirrors
- Power Seats
- Power Top/Sunroof
- Power Windows
- Radio
- Starting/Charging
- Supplemental Restraints
- Transmission
- Warning Systems
- Wiper/Washer
- Using lemon2025'S System Wiring Diagrams
- System Wiring Diagrams - 2D Coupe
- Engine Mechanical
- Accessory Drive Belts
- Cooling System Specifications & Drive Belt Routing
- Cooling System Bleeding
- Belt Adjustment
- Belt Routing
- NEON & PT CRUISER (2.0L Neon & 2.0L & 2.4L PT Cruiser)
- SEBRING CONVERTIBLE, SEBRING SEDAN & STRATUS SEDAN (2.4L Sebring Convertible, Sebring Sedan & Stratus Sedan)
- SEBRING CONVERTIBLE, SEBRING SEDAN & STRATUS SEDAN (2.7L Sebring Convertible, Sebring Sedan & Stratus Sedan)
- SEBRING COUPE & STRATUS COUPE (2.4L Sebring Coupe & Stratus Coupe)
- SEBRING COUPE & STRATUS COUPE (3.0L Sebring Coupe & Stratus Coupe)
- CONCORDE, Intrepid, LHS, Prowler & 300M
- Specifications
- Cooling System Specifications & Drive Belt Routing
- Auxiliary Emission Control Systems
- Emission Control System Visual Inspection Procedures - General Information
- * Please Read This First *
- Emission Control Labels
- Emission Control Visual Inspection
- Notes
- Positive Crankcase Ventilation (PCV)
- Thermostatic Air Cleaner (TAC)
- Fuel Evaporative System (EVAP)
- Catalytic Converters
- Fill Pipe RESTRICTOR (Fr)
- Exhaust Gas RECIRCULATION (EGR) System
- Spark Controls (SPK)
- Air Injection System (AIS)
- Oxygen Sensor (O2)
- Computerized Engine Controls (CEC)
- Early Fuel Evaporation (EFE)
- Emission Maintenance Reminder Light (EMR) (If Equipped)
- Malfunction Indicator Light (Mil)
- Emission Control System Visual Inspection Procedures - General Information
- Electric Cooling Fans - Coupe
- Cooling System (Mechanical)
- Cooling System Specifications & Drive Belt Routing
- Cooling System Bleeding
- Belt Adjustment
- Belt Routing
- NEON & PT CRUISER (2.0L Neon & 2.0L & 2.4L PT Cruiser)
- SEBRING CONVERTIBLE, SEBRING SEDAN & STRATUS SEDAN (2.4L Sebring Convertible, Sebring Sedan & Stratus Sedan)
- SEBRING CONVERTIBLE, SEBRING SEDAN & STRATUS SEDAN (2.7L Sebring Convertible, Sebring Sedan & Stratus Sedan)
- SEBRING COUPE & STRATUS COUPE (2.4L Sebring Coupe & Stratus Coupe)
- SEBRING COUPE & STRATUS COUPE (3.0L Sebring Coupe & Stratus Coupe)
- CONCORDE, Intrepid, LHS, Prowler & 300M
- Specifications
- Engine Cooling System - Coupe
- General Description
- Engine Cooling Diagnosis
- Introduction
- Troubleshooting Strategy
- Symptom Chart
- Symptom Procedures
- INSPECTION PROCEDURE 1: Coolant Leak
- INSPECTION PROCEDURE 2: Engine Overheating
- INSPECTION PROCEDURE 3: Radiator Fan and Condenser Fan do not Operate
- INSPECTION PROCEDURE 4: Radiator Fan and Condenser Fan do not Change Speed or Stop
- INSPECTION PROCEDURE 5: Radiator Fan does not Operate
- INSPECTION PROCEDURE 6: Condenser Fan does not Operate
- On-Vehicle Service
- Radiator
- Thermostat
- Water Pump
- Water Hose And Water Pipe
- Specifications
- Cooling System Specifications & Drive Belt Routing
- Mechanical
- 3.0L SOHC Engine - Coupe
- General Description
- Engine Diagnosis
- Special Tools
- On Vehicle Service
- Engine Assembly
- Camshaft And Camshaft Oil Seal
- Oil Pan
- Crankshaft Front Oil Seal
- Crankshaft Rear Oil Seal
- Cylinder Head Gasket
- Timing Belt
- Specifications
- Rocker Arms And Camshaft
- Cylinder Head And Valves
- Oil Pan And Oil Pump
- Removal And Installation
- Notes
- Removal Service Point
- Installation Service Points
- >> A << Inner Rotor/Outer Rotor Installation
- >> B << Oil Pump Case Assembly Installation
- >> C << Crankshaft Front Oil Seal Installation
- >> D << Oil Pan, Upper Installation
- >> E << Oil Pan, Lower Installation
- >> F << Drain Plug Gasket Installation
- >> G << Oil Filter Installation
- >> H << Oil Pressure Switch Installation
- Inspection
- Removal And Installation
- Piston And Connecting Rod
- Crankshaft And Cylinder Block
- Water Pump
- Water Hose & Water Pipe
- 3.0L SOHC Engine - Coupe
- Starter
- Timing Belt Replacement - 3.0L - SOHC (Coupe)
- Accessory Drive Belts
- Engine Performance
- Engine Controls - On-Vehicle Adjustments - Coupe
- Application
- Emissions
- EGR Function Testing - CHRYSLER Cars
- Emission Applications
- Emission Control Abbreviations
- State Emission Standards - Diesel
- State Emission Standards - Gas
- ALASKA
- ARIZONA
- CALIFORNIA
- Colorado
- CONNECTICUT
- DELAWARE
- District Of COLUMBIA
- GEORGIA
- IDAHO
- ILLINOIS
- INDIANA
- KENTUCKY
- MARYLAND
- MASSACHUSETTS
- MISSOURI
- NEVADA
- New Jersey
- New MEXICO
- New YORK
- North CAROLINA
- OHIO
- OREGON
- PENNSYLVANIA
- RHODE Island
- TENNESSEE
- TEXAS
- UTAH
- VIRGINIA
- WASHINGTON
- WISCONSIN
- U. S. EPA ASM2525 & ASM5015 Start-Up Emission Standards
- U. S. EPA Revised Final ASM Emission Standards (ASM5015 & ASM2525)
- U.S. EPA Im240 Emission Standards
- Mode 6 - CHRYSLER
- Introduction
- 1996
- 1997-1998
- 1999
- 2000
- 2001
- 2002
- 2003-2004
- 2005
- 2006
- 2007
- 2007-09 Diesel Engines
- 2008
- 2008-10 Viper
- 2009-10 Pt Cruiser
- 2009 - All Vehicles With V6 Or V8 Engines
- 2009 Vehicles With The "World I4" 4 Cylinder Engine
- 2010 Vehicles
- 2011 Vehicles
- 2012 Vehicles
- Engine Controls - Pin Voltage Charts - Coupe
- Remove, Overhaul & Install
- Engine Controls - Removal, Overhaul & Installation - Coupe
- Introduction
- Cooling System
- Computerized Engine Controls
- Engine Sensors & Switches
- A/C Dual Pressure Switch
- Brake Switch
- Camshaft Position Sensor
- Crankshaft Position Sensor
- Downstream Oxygen Sensor
- Engine Coolant Temperature Sensor
- Fuel Tank Differential Pressure Sensor
- Intake Air Temperature Sensor
- Knock Sensor
- Manifold Differential Pressure Sensor
- Output Shaft Speed Sensor
- Park/Neutral Switch
- Power Steering Pressure Switch
- Throttle Position Sensor
- Upstream Oxygen Sensor
- Vehicle Speed Sensor
- Volume Airflow Sensor
- Motors, Relays & Solenoids
- Ignition System
- Fuel Systems
- Emission Systems
- Torque Specifications
- Engine Controls - Removal, Overhaul & Installation - Coupe
- Sensor Range Charts
- Engine Controls - Service & Adjustment Specifications
- Introduction
- Capacities
- Quick-Service
- Service Intervals & Specifications
- Replacement Intervals (CONCORDE, Intrepid & 300M)
- Replacement Intervals (Neon)
- Replacement Intervals (Prowler)
- Replacement Intervals (Pt Cruiser)
- Replacement Intervals (SEBRING Convertible, SEBRING Sedan & Stratus Sedan)
- Replacement Intervals (SEBRING Coupe & Stratus Coupe)
- Replacement Intervals (Viper)
- Drive Belt Adjustment - CONCORDE, Intrepid & 300M
- Drive Belt Adjustment - Neon
- Drive Belt Adjustment - Prowler
- Drive Belt Adjustment - Pt Cruiser
- Drive Belt Adjustment - SEBRING Convertible, SEBRING Sedan & Stratus Sedan
- Drive Belt Adjustment - SEBRING Coupe & Stratus Coupe
- Drive Belt Adjustment - Viper
- Service Intervals & Specifications
- Mechanical Checks
- Ignition System
- Fuel System
- System
- Engine Controls - Basic Diagnostic Procedures - Coupe
- Engine Controls - Self-Diagnostics - Coupe - 3.0L
- Introduction
- Self-Diagnostic System
- Programming
- Malfunction Indicator Light Diagnosis
- Scan Tool Communications
- Summary
- Component Locations
- Connector Identification
- Diagnostic Trouble Code Definitions
- Diagnostic Tests
- DTC P0101: Volume Airflow Circuit Range/Performance Problem
- DTC P0102: Volume Airflow Circuit Low Input
- DTC P0106: Barometric Pressure Circuit Range/Performance Problem
- DTC P0107: Barometric Pressure Circuit Low Input
- DTC P0108: Barometric Pressure Circuit High Input
- DTC P0111: Intake Air Temperature Circuit Malfunction
- DTC P0112: Intake Air Temperature Circuit Low Input
- DTC P0113: Intake Air Temperature Circuit High Input
- DTC P0116: Engine Coolant Temperature Circuit Range/Performance Problem
- DTC P0117: Engine Coolant Temperature Circuit Low Input
- DTC P0118: Engine Coolant Temperature Circuit High Input
- DTC P0121: Throttle Position Sensor Circuit Range/Performance Problem
- DTC P0122: Throttle Position Sensor Circuit Low Input
- DTC P0123: Throttle Position Sensor Circuit High Input
- DTC P0125: Insufficient Coolant Temperature For Closed Loop Fuel Control
- DTC P0128: Coolant Thermostat Malfunction
- DTC P0132: Heated Oxygen Sensor (Bank 1, Sensor 1) Circuit High Voltage
- DTC P0133: Heated Oxygen Sensor (Bank 1, Sensor 1) Circuit Slow Response
- DTC P0134: Heated Oxygen Sensor (Bank 1, Sensor 1) Circuit No Activity Detected
- DTC P0135: Heated Oxygen Sensor (Bank 1, Sensor 1) Heater Circuit
- DTC P0137: Heated Oxygen Sensor (Bank 1, Sensor 2) Circuit Low Voltage
- DTC P0138: Heated Oxygen Sensor (Bank 1, Sensor 2) Circuit High Voltage
- DTC P0139: Heated Oxygen Sensor (Bank 1, Sensor 2) Circuit Slow Response
- DTC P0141: Heated Oxygen Sensor (Bank 1, Sensor 2) Heater Circuit
- DTC P0152: Heated Oxygen Sensor (Bank 2, Sensor 1) Circuit High Voltage
- DTC P0153: Heated Oxygen Sensor (Bank 2, Sensor 1) Circuit Slow Response
- DTC P0154: Heated Oxygen Sensor (Bank 2, Sensor 1) Circuit No Activity Detected
- DTC P0155: Heated Oxygen Sensor (Bank 2, Sensor 1) Heater Circuit
- DTC P0157: Heated Oxygen Sensor (Bank 2, Sensor 2) Circuit Low Voltage
- DTC P0158: Heated Oxygen Sensor (Bank 2, Sensor 2) Circuit High Voltage
- DTC P0159: Heated Oxygen Sensor (Bank 2, Sensor 2) Circuit Slow Response
- DTC P0161: Heated Oxygen Sensor (Bank 2, Sensor 2) Heater Circuit
- DTC P0171: System Too Lean Fuel Trim Circuit (Bank 1)
- DTC P0172: System Too Rich Fuel Trim Circuit (Bank 1)
- DTC P0174: System Too Lean Fuel Trim Circuit (Bank 2)
- DTC P0175: System Too Rich Fuel Trim Circuit (Bank 2)
- DTC P0181: Fuel Temperature Sensor Circuit Range/Performance
- DTC P0182: Fuel Temperature Sensor Circuit Low Input
- DTC P0183: Fuel Temperature Sensor Circuit High Input
- DTCS P0201, P0203 & P0205: Injector Circuit Malfunction (Cylinders No. 1, 3 & 5)
- DTCS P0202, P0204 & P0206: Injector Circuit Malfunction (Cylinders No. 2, 4 & 6)
- DTC P0300: Random/Multiple Cylinder Misfire Detected
- DTCS P0301-P0306: Cylinder 1 Misfire Detected, Cylinder 2 Misfire Detected, Cylinder 3 Misfire Detected, Cylinder 4 Misfire Detected, 5 Misfire Detected, Cylinder 6 Misfire Detected
- DTC P0325: Knock Sensor Circuit
- DTC P0335: Crankshaft Position Sensor Circuit
- DTC P0340: Camshaft Position Sensor Circuit
- DTC P0401: Exhaust Gas RECIRCULATION Flow Insufficient Detected
- DTC P0403: Exhaust Gas RECIRCULATION Control Circuit
- DTC P0421: Warm Up Catalyst Efficiency Below Threshold (Bank 1)
- DTC P0431: Warm Up Catalyst Efficiency Below Threshold (Bank 2)
- DTC P0441: Evaporative Emission Control System Incorrect Purge Flow
- DTC P0442: Evaporative Emission Control System Leak Detected (Small Leak)
- DTC P0443: Evaporative Emission Control System Purge Control Valve
- DTC P0446: Evaporative Emission Control System Vent Control Circuit
- DTC P0451: Evaporative Emission Control System Pressure Sensor Range/Performance
- DTC P0452: Evaporative Emission Control System Pressure Sensor Low Input
- DTC P0453: Evaporative Emission Control System Pressure Sensor High Input
- DTC P0455: Evaporative Emission Control System Leak Detected (Gross Leak)
- DTC P0456: Evaporative Emission Control System Leak Detected (Very Small Leak)
- DTC P0461: Fuel Level Sensor Circuit Range/Performance Fuel Gauge Unit Circuit
- DTC P0500: Vehicle Speed Sensor Vehicle Speed Sensor Circuit (M/T)
- DTC P0506: Idle Control System Rpm Less Than Expected Idle Air Control Motor Circuit
- DTC P0507: Idle Control System Rpm More Than Expected Idle Air Control Motor Circuit
- DTC P0551: Power Steering Pressure Sensor Circuit Range/Performance
- DTC P1400: Manifold Differential Pressure Sensor
- DTC P1500: Generator Fr Terminal Circuit
- DTC P1603: Battery Backup Circuit Malfunction
- DTC P1610: Immobilizer Malfunction
- Verifying Repairs
- Engine Controls - System & Component Testing - Coupe - 3.0L
- Introduction
- Computerized Engine Controls
- Engine Sensors & Switches
- Barometric Pressure Sensor
- Brake Switch
- Camshaft Position Sensor
- Clutch Interlock Switch
- Crankshaft Position Sensor
- Engine Coolant Temperature Sensor
- Fuel Tank Differential Pressure Sensor
- Heated Oxygen Sensor
- Intake Air Temperature Sensor
- Knock Sensor
- Manifold Differential Pressure Sensor
- Output Shaft Speed Sensor
- Park/Neutral Position Switch
- Power Steering Pressure Switch
- Throttle Position Sensor
- Transaxle Range Sensor
- Vehicle Speed Sensor
- Volume Airflow Sensor
- Motors, Relays & Solenoids
- Fuel Systems
- Idle Control Systems
- Unstable Idle (Rough Idle, Hunting)
- Idle Speed High
- Idle Speed Low
- Stalls At Idle When Cold
- Stalls At Idle When Hot
- Stalls When Accelerating
- Stalls When Decelerating
- Hesitation, Sag Or Stumble
- Acceleration Shock
- Deceleration Shock
- Poor Acceleration
- Surge
- Knock
- Dieseling
- Improper Idle Speed When A/C Is Operating
- Idle Up Operation
- Idle Air Control Motor
- Ignition Systems
- Emission Systems & Sub-Systems
- Miscellaneous Controls
- Engine Controls - Trouble Shooting - No Codes - Coupe
- Introduction
- Symptoms
- Symptom Diagnosis
- Engine Cranks, Won't Start
- Hard To Start
- Starts But Stalls
- Hesitation, Sag Or Stumble
- Acceleration Shock (Engine Misfire)
- Deceleration Shock
- Poor Acceleration
- Surging
- Knocking
- Dieseling When Shut Off
- Unstable Idle
- Idle Speed Too High
- Idle Speed Too Low
- Engine Stalls When Cold
- Engine Stalls When Hot
- Engine Stalls When Accelerating
- Engine Stalls When Decelerating
- INTERMITTENTS
- O2 Sensor Location & Identification
- Testing & Diagnosis
- Engine Controls - Basic Diagnostic Procedures - Coupe
- Engine Controls - Self-Diagnostics - Coupe - 3.0L
- Introduction
- Self-Diagnostic System
- Programming
- Malfunction Indicator Light Diagnosis
- Scan Tool Communications
- Summary
- Component Locations
- Connector Identification
- Diagnostic Trouble Code Definitions
- Diagnostic Tests
- DTC P0101: Volume Airflow Circuit Range/Performance Problem
- DTC P0102: Volume Airflow Circuit Low Input
- DTC P0106: Barometric Pressure Circuit Range/Performance Problem
- DTC P0107: Barometric Pressure Circuit Low Input
- DTC P0108: Barometric Pressure Circuit High Input
- DTC P0111: Intake Air Temperature Circuit Malfunction
- DTC P0112: Intake Air Temperature Circuit Low Input
- DTC P0113: Intake Air Temperature Circuit High Input
- DTC P0116: Engine Coolant Temperature Circuit Range/Performance Problem
- DTC P0117: Engine Coolant Temperature Circuit Low Input
- DTC P0118: Engine Coolant Temperature Circuit High Input
- DTC P0121: Throttle Position Sensor Circuit Range/Performance Problem
- DTC P0122: Throttle Position Sensor Circuit Low Input
- DTC P0123: Throttle Position Sensor Circuit High Input
- DTC P0125: Insufficient Coolant Temperature For Closed Loop Fuel Control
- DTC P0128: Coolant Thermostat Malfunction
- DTC P0132: Heated Oxygen Sensor (Bank 1, Sensor 1) Circuit High Voltage
- DTC P0133: Heated Oxygen Sensor (Bank 1, Sensor 1) Circuit Slow Response
- DTC P0134: Heated Oxygen Sensor (Bank 1, Sensor 1) Circuit No Activity Detected
- DTC P0135: Heated Oxygen Sensor (Bank 1, Sensor 1) Heater Circuit
- DTC P0137: Heated Oxygen Sensor (Bank 1, Sensor 2) Circuit Low Voltage
- DTC P0138: Heated Oxygen Sensor (Bank 1, Sensor 2) Circuit High Voltage
- DTC P0139: Heated Oxygen Sensor (Bank 1, Sensor 2) Circuit Slow Response
- DTC P0141: Heated Oxygen Sensor (Bank 1, Sensor 2) Heater Circuit
- DTC P0152: Heated Oxygen Sensor (Bank 2, Sensor 1) Circuit High Voltage
- DTC P0153: Heated Oxygen Sensor (Bank 2, Sensor 1) Circuit Slow Response
- DTC P0154: Heated Oxygen Sensor (Bank 2, Sensor 1) Circuit No Activity Detected
- DTC P0155: Heated Oxygen Sensor (Bank 2, Sensor 1) Heater Circuit
- DTC P0157: Heated Oxygen Sensor (Bank 2, Sensor 2) Circuit Low Voltage
- DTC P0158: Heated Oxygen Sensor (Bank 2, Sensor 2) Circuit High Voltage
- DTC P0159: Heated Oxygen Sensor (Bank 2, Sensor 2) Circuit Slow Response
- DTC P0161: Heated Oxygen Sensor (Bank 2, Sensor 2) Heater Circuit
- DTC P0171: System Too Lean Fuel Trim Circuit (Bank 1)
- DTC P0172: System Too Rich Fuel Trim Circuit (Bank 1)
- DTC P0174: System Too Lean Fuel Trim Circuit (Bank 2)
- DTC P0175: System Too Rich Fuel Trim Circuit (Bank 2)
- DTC P0181: Fuel Temperature Sensor Circuit Range/Performance
- DTC P0182: Fuel Temperature Sensor Circuit Low Input
- DTC P0183: Fuel Temperature Sensor Circuit High Input
- DTCS P0201, P0203 & P0205: Injector Circuit Malfunction (Cylinders No. 1, 3 & 5)
- DTCS P0202, P0204 & P0206: Injector Circuit Malfunction (Cylinders No. 2, 4 & 6)
- DTC P0300: Random/Multiple Cylinder Misfire Detected
- DTCS P0301-P0306: Cylinder 1 Misfire Detected, Cylinder 2 Misfire Detected, Cylinder 3 Misfire Detected, Cylinder 4 Misfire Detected, 5 Misfire Detected, Cylinder 6 Misfire Detected
- DTC P0325: Knock Sensor Circuit
- DTC P0335: Crankshaft Position Sensor Circuit
- DTC P0340: Camshaft Position Sensor Circuit
- DTC P0401: Exhaust Gas RECIRCULATION Flow Insufficient Detected
- DTC P0403: Exhaust Gas RECIRCULATION Control Circuit
- DTC P0421: Warm Up Catalyst Efficiency Below Threshold (Bank 1)
- DTC P0431: Warm Up Catalyst Efficiency Below Threshold (Bank 2)
- DTC P0441: Evaporative Emission Control System Incorrect Purge Flow
- DTC P0442: Evaporative Emission Control System Leak Detected (Small Leak)
- DTC P0443: Evaporative Emission Control System Purge Control Valve
- DTC P0446: Evaporative Emission Control System Vent Control Circuit
- DTC P0451: Evaporative Emission Control System Pressure Sensor Range/Performance
- DTC P0452: Evaporative Emission Control System Pressure Sensor Low Input
- DTC P0453: Evaporative Emission Control System Pressure Sensor High Input
- DTC P0455: Evaporative Emission Control System Leak Detected (Gross Leak)
- DTC P0456: Evaporative Emission Control System Leak Detected (Very Small Leak)
- DTC P0461: Fuel Level Sensor Circuit Range/Performance Fuel Gauge Unit Circuit
- DTC P0500: Vehicle Speed Sensor Vehicle Speed Sensor Circuit (M/T)
- DTC P0506: Idle Control System Rpm Less Than Expected Idle Air Control Motor Circuit
- DTC P0507: Idle Control System Rpm More Than Expected Idle Air Control Motor Circuit
- DTC P0551: Power Steering Pressure Sensor Circuit Range/Performance
- DTC P1400: Manifold Differential Pressure Sensor
- DTC P1500: Generator Fr Terminal Circuit
- DTC P1603: Battery Backup Circuit Malfunction
- DTC P1610: Immobilizer Malfunction
- Verifying Repairs
- Engine Controls - System & Component Testing - Coupe - 3.0L
- Introduction
- Computerized Engine Controls
- Engine Sensors & Switches
- Barometric Pressure Sensor
- Brake Switch
- Camshaft Position Sensor
- Clutch Interlock Switch
- Crankshaft Position Sensor
- Engine Coolant Temperature Sensor
- Fuel Tank Differential Pressure Sensor
- Heated Oxygen Sensor
- Intake Air Temperature Sensor
- Knock Sensor
- Manifold Differential Pressure Sensor
- Output Shaft Speed Sensor
- Park/Neutral Position Switch
- Power Steering Pressure Switch
- Throttle Position Sensor
- Transaxle Range Sensor
- Vehicle Speed Sensor
- Volume Airflow Sensor
- Motors, Relays & Solenoids
- Fuel Systems
- Idle Control Systems
- Unstable Idle (Rough Idle, Hunting)
- Idle Speed High
- Idle Speed Low
- Stalls At Idle When Cold
- Stalls At Idle When Hot
- Stalls When Accelerating
- Stalls When Decelerating
- Hesitation, Sag Or Stumble
- Acceleration Shock
- Deceleration Shock
- Poor Acceleration
- Surge
- Knock
- Dieseling
- Improper Idle Speed When A/C Is Operating
- Idle Up Operation
- Idle Air Control Motor
- Ignition Systems
- Emission Systems & Sub-Systems
- Miscellaneous Controls
- Engine Controls - Trouble Shooting - No Codes - Coupe
- Introduction
- Symptoms
- Symptom Diagnosis
- Engine Cranks, Won't Start
- Hard To Start
- Starts But Stalls
- Hesitation, Sag Or Stumble
- Acceleration Shock (Engine Misfire)
- Deceleration Shock
- Poor Acceleration
- Surging
- Knocking
- Dieseling When Shut Off
- Unstable Idle
- Idle Speed Too High
- Idle Speed Too Low
- Engine Stalls When Cold
- Engine Stalls When Hot
- Engine Stalls When Accelerating
- Engine Stalls When Decelerating
- INTERMITTENTS
- O2 Sensor Location & Identification
- Theory and Operation
- Engine Controls - Theory & Operation - Coupe
- Introduction
- Computerized Engine Controls
- Engine Control Module/Powertrain Control Module
- Input Devices
- Notes
- A/C Pressure Sensor
- A/C Switch
- Battery Voltage
- Camshaft Position (CMP) Sensor
- Crankshaft Position (CKP) Sensor
- Engine Coolant Temperature (ECT) Sensor
- Fuel Level Sensor
- Heated Oxygen Sensor (HO2S)
- Ignition Switch
- Intake Air Temperature (IAT) Sensor
- Knock Sensor (KS)
- Output Shaft Speed (OSS) Sensor
- Park/Neutral (P/N) Switch
- Power Steering Pressure (PSP) Switch
- Sensor Return
- Throttle Position (TP) Sensor
- Vehicle Speed Sensor (VSS)
- Volume Airflow (VAF) Sensor
- Output Signals
- Notes
- Data Link Connector (DLC)
- Distributorless Ignition System (DIS)
- Hall Effect Ignition System
- Evaporative Emission Purge Solenoid
- Evaporative Emission Ventilation Solenoid
- Fuel Injectors
- Fuel Pump Relays
- Generator
- Idle Air Control (IAC) Motor
- In-Tank Fuel Pump
- Limp-In Mode
- Malfunction Indicator Light (MIL)
- Radiator Fan Controller
- Tachometer
- Fuel System
- Ignition System
- Emission Systems
- Self-Diagnostic System
- Miscellaneous Controls
- Engine Controls - Theory & Operation - Coupe
- Vacuum Diagrams
- Wiring Diagrams
- General Information
- Abbreviations
- Basic Trouble Shooting
- Basic Trouble Shooting - General Information
- Commonly Used Abbreviations - General Information
- Emission Control Abbreviations
- Engine Performance - Trouble Shooting - General Information
- Brakes
- Anti-Lock Brake Safety Precautions - General Information
- Map - Brake Systems
- Brake Systems
- Notes
- Map Standards Of Service
- The Map Process - Overview
- The Map Process - Overview Of Service Requirements And Suggestions
- Accelerometers
- Accumulators
- Anchor Pins
- Anti-Lock Brake Control Assembly(Module)
- Anti-Lock Brake Controller
- Anti-Lock Brake Systems
- Axle Seal
- Backing Plates
- Bleeder Screw
- Brake Abs Active Light (Blue)
- Brake Fluid
- Brake Friction Material
- Brake On - Off Switch
- Brake Pads
- Brake Pedals
- Brake Shoe Hardware
- Brake Shoes
- Brake Stoplight Switches
- Brake Warning Light (Amber)
- Brake Warning Light (Red)
- Bulb Sockets
- Bulbs And LEDS
- Caliper Hardware
- Caliper Mounting Pin
- Caliper Piston
- Caliper Shim
- Caliper Slider Pin (Bolt) Dust Boot
- Caliper Slider Pin (Bolt)
- Calipers
- Combination Valve
- Controllers
- Digital Ratio Axle Controllers And Buffers (Drab And Dram)
- Disable Switches
- Drums
- Electrical Brake Pumps
- Electrical Park Motor
- Electrical Pumps And Motors
- Electro-Magnetic Interference
- Electronic Brake Control Modulator
- Electronic Brake Distribution
- Electronic Brake Traction Control Module
- Electronic Controllers
- Electronic Traction Control
- External Brake Cable
- Flow Control Valve
- Fluid Level Sensor Switches
- Fluid
- Four Wheel Drive Switches
- Friction Material
- G Sensors
- Gaskets
- Gravitational Switches
- Grease Seal
- Height Sensing Proportioning Valve
- High Pressure Accumulator
- Hoses
- Hub
- Hydraulic Control Unit
- Hydraulic Modulators
- Hydro-Boosters
- Hydro-Electric Boosters (POWERMASTER)
- Ignition Disable Switches
- Lamp Driver Relay
- Lateral Acceleration Switches
- LEDS
- Lenses
- Low Pressure Accumulator
- Lug Nut
- Master Cylinder Cover Gasket
- Master Cylinders
- Modulators
- Motor Pack
- Motors
- Pads
- Parking Brake Cable
- Parking Brake Mechanism
- Parking Brake Shoes
- Parking Brake Switches
- Parking Brake Systems
- Pedal Travel Switches
- Pedals
- Power Distribution Center
- POWERMASTER
- Pressure Differential Switches
- Pressure Switches
- Pressure Transducers
- Proportioning Valve
- Pumps
- Relays
- RELUCTOR (Speed) Ring
- Rotors
- Self-Adjusting Systems
- Shoe Hardware
- Shoes
- Sockets
- Speed Sensor (RELUCTOR) Ring
- Speed Sensors (Electronic Wheel And Vehicle)
- Star Wheel
- Steel Brake Lines
- Stoplight Switches
- Stroke Sensor
- Switches
- Tires
- Tone Ring
- Toothed Rings (Tone Wheel)
- Traction Control System (TCS)
- Transfer Tubes
- Vacuum Boosters
- Vacuum Hoses
- Valves
- Wear Indicator
- Wheel Attachment Hardware
- Wheel Bearings, Races And Seals
- Wheel Cylinders
- Wiring Harnesses
- Yaw Rate Sensor
- Brake System CHECKSHEET
- Reason Code Explanation
- Automotive Terminology & Definitions
- Brake Systems
- Map - Routine Inspection Reference Guide
- Routine Inspection Reference Guide
- Notes
- Map Standards Of Service
- The Map Process - Overview
- The Map Process - Overview Of Service Requirements And Suggestions
- Maintenance Overview
- Antifreeze/Coolant
- Visual Inspection
- Radiator Cap Test
- Engine Fan
- Cooling System Power Flush And Refill
- Belts (Except Timing Belts)
- Belt TENSIONER
- Automatic Transmission Fluid
- Automatic Transmission Fluid Exchange & Filter Replacement
- Engine Oil
- Air Filters
- Cabin Air Filter
- Brake Fluid
- Battery
- Battery Cables
- Power Steering
- Power Steering Fluid
- Wiper Blades
- Routine Inspection CHECKSHEET
- Routine Inspection - UICS
- Brake Systems
- Drivetrain And Transmission
- Notes
- Automatic Transmission Fluid
- Clutch Master Cylinders
- Cooler Lines
- Coolers
- Differential Fluid
- Drain Plugs And Gaskets
- Filters And Screens
- Fluids And Lubricants
- Hoses, Lines, And Tubes
- Hydraulic Fluid
- Lubricants
- Manual Transmission Fluid
- Mounts (Engine, Transaxle And Transmission)
- Transfer Case Fluid
- Vacuum Hoses
- Electrical Systems
- Engine Performance And Maintenance
- Notes
- Accessory Belts
- Air Filter Elements
- Air Filter Gaskets
- Air Filter Housings And Gaskets
- Air Pump Belts
- Batteries
- Battery Connectors
- Belt Idler Assemblies (Accessory And Cam Belts)
- Belt TENSIONERS (Accessory And Cam Belt)
- Chemical Engine DECARBONIZATION
- Combustion Chamber Cleaning
- Coolant Recovery Tanks
- Coolant
- Distributor Caps
- Distributor Rotors
- Engine Cooling Systems
- Engine DECARBONIZATION
- Engine Oil Drain Plugs And Gaskets
- Engine Oil Filters And Canisters
- Engine Oil
- Fuel Filters
- Fuel Injector Cleaning
- Fuel Injectors
- Fuel System Cleaning Service
- Hose Clamps
- Hose Connectors
- Hose Couplers
- Hoses And Tubes (Fuel Lines, Radiator, Vacuum, By-Pass, Heater, Recovery Tank And Oil Coolers)
- Ignition Wires (Secondary)
- Intake Cleaning
- O2 Sensors
- PCV Breather Elements
- PCV Valves
- Radiator Caps And Pressurized Expansion Tank Caps
- Spark Plugs
- Thermostats And Housings
- Throttle Body Cleaning
- Timing Belts
- Vacuum Hoses, Tubes And Connections (Non-Metallic)
- Exhaust Systems
- Heating, Ventilation And Air Conditioning Systems
- Steering And Suspension, Wheel Alignment, Wheels And Tires
- Wheel & Tire Supplement
- Reason Code Explanation
- Automotive Terminology & Definitions
- Routine Inspection Reference Guide
- Check Lists
- Computer Relearn Procedures
- Introduction
- CHRYSLER Corp.
- A/C Calibration (Caravan, Town & Country, & Voyager)
- A/C Calibration (CONCORDE, Intrepid & 300M)
- Body Control Module (CONCORDE, Intrepid, SEBRING Convertible, SEBRING Sedan, Stratus Sedan & 300M)
- Drive Learn Procedure (DAKOTA - 4.7L, DURANGO - 4.7L & Ram Pickup 1500 - 4.7L)
- Notes
- Procedure To Learn A Smooth 1st Neutral To Drive Shift
- Procedure To Learn A Smooth Neutral To Drive Garage Shift
- Procedure To Learn The 1st 2-3 Shift After A Restart Or Shift To Reverse
- Procedure To Learn A Smooth 2-3 & 3-4 Upshift
- Procedure To Learn A Smooth 4-3 Coastdown & Part Throttle 4-3 Kickdown
- Procedure To Learn A Smooth 1-2 Upshift & 3-2 Kickdown
- Procedure To Learn A Smooth Manual 2-1 Pulldown Shift As Well As A Neutral To Reverse Shift
- Procedure To Learn A Smooth Neutral To Reverse Shift
- Procedure To Learn A Smooth 4-5 Upshift for 545RFE
- Engine Control Module Programming (Diesel)
- Immobilizer System (SEBRING Coupe & Stratus Coupe)
- Instrument Cluster (Ram Van & Ram Wagon)
- Pinion Factor Procedure
- Power Liftgate Learn Cycle (Caravan & Town & Country)
- Power Sliding Door Learn Cycle (Caravan & Town & Country)
- Powertrain Control Module Programming (Except Ram Pickup 2500 & 3500 - Gasoline, Ram Van & Ram Wagon)
- Powertrain Control Module Programming (Ram Pickup 2500 & 3500 - Gasoline, Ram Van & Ram Wagon)
- Sentry Key Immobilizer Module Programming
- Programming Ignition Keys To Sentry Key Immobilizer Module
- Torque Converter Clutch Break-In Procedure (CONCORDE, Intrepid & 300M)
- Transmission Shift Quality Quick Learn Procedure (DAKOTA - 4.7L, DURANGO - 4.7L & Ram Pickup 1500 - 4.7L)
- Transaxle Shift Quality Quick Learn Procedure
- Vehicle DRIVEABILITY Computer Relearn Procedure
- Ford Motor Co.
- General Motors (Cars)
- Notes
- Crankshaft Position Sensor System Variation Learn Procedure
- Alero, Aurora - 4.0L, Bonneville, Cavalier - 2.2L, Century, Corvette, Deville, Eldorado, Grand Am, Grand Prix, Impala, LeSabre, Malibu, Monte Carlo, Park Avenue, Regal, Seville & Sunfire - 2.2L
- Camaro & Firebird - 3.8L
- Camaro & Firebird - 5.7L
- Cavalier & Sunfire - 2.4L
- Intrigue - 3.5L
- Saturn - 1.9L
- Saturn - 2.2L
- Engine Control Module
- Idle Air Control Valve Learn Procedure
- Powertrain Control Module
- Alero - 2.2L, Cavalier, Grand Am - 2.2L, Saturn - 1.9L & Sunfire
- Remote Programming (Alero - 3.4L, Aurora, Bonneville, Camaro, Century, Deville, Eldorado, Firebird, Grand Am, Grand Prix, Impala, Intrigue, LeSabre, Malibu, Monte Carlo, Park Avenue, Regal & Seville)
- Off-Board Programming (Alero - 3.4L, Aurora, Bonneville, Camaro, Century, Deville, Eldorado, Firebird, Grand Am, Grand Prix, Impala, Intrigue, LeSabre, Malibu, Monte Carlo, Park Avenue, Regal & Seville)
- Remote Programming (Corvette)
- Off-Board Programming (Corvette)
- Theft Deterrent System Components
- 10-Minute Learn Procedure (Alero, Cavalier, Century, Corvette, Grand Am, Impala, Malibu, Monte Carlo, Regal & Sunfire)
- 30-Minute Learn Procedure (Alero, Cavalier, Century, Corvette, Grand Am, Impala, Malibu, Monte Carlo, Regal & Sunfire)
- Set Up A New Theft Deterrent Control Module (Aurora, Bonneville, Deville, Eldorado, Intrigue, LeSabre, Park Avenue & Seville)
- 10-Minute Learn Procedure (Aurora, Bonneville, Deville, Eldorado, Intrigue, LeSabre, Park Avenue & Seville)
- 30-Minute Learn Procedure (Aurora, Bonneville, Deville, Eldorado, Intrigue, LeSabre, Park Avenue & Seville)
- Passlock™ Anti-Theft Seed & Key Method (Saturn - 1.9L)
- Passlock™ Anti-Theft Auto Learn Method (Saturn - 1.9L)
- Auto Learn Method (Saturn - 2.2L & 3.0L)
- Saturn Service Stall Method (Saturn - 2.2L & 3.0L)
- Throttle Body Relearn Procedure
- Throttle Position Sensor Learn Procedure
- General Motors (Trucks & Vans)
- Notes
- Crankshaft Position Sensor System Variation Learn Procedure
- Avalanche, Astro, Aztek, Blazer, Bravada, Cab & Chassis - 8.1L, Chevy Express - 4.3L, 5.0L, 5.7L & 8.1L, Cutaway - 5.7L & 8.1L, Envoy, Envoy XL, Escalade, Escalade EXT, Jimmy Canadian, Montana, Rendezvous, RV Cutaway - 5.7L & 8.1L, S10 Pickup, Safari, Savana - 4.3L, 5.0L, 5.7L & 8.1L, Savana Camper Special -5.7L & 8.1L, Savana Special - 5.7L & 8.1L, Sierra - 4.3L, 4.8L, 5.3L, 6.0L & 8.1L, Silhouette, Silverado - 4.3L, 4.8L, 5.3L, 6.0L & 8.1L, Sonoma, Suburban, Tahoe, Trailblazer, Venture, Yukon & Yukon XL
- Vue - 2.2L
- Engine Control Module Programming
- Fuel Injection Pump Top Dead Center Offset Adjustment
- Glow Plug System Relearn Procedure
- Powertrain Control Module
- Remote Programming (Avalanche, Astro, Aztek, Blazer, Bravada, Cab & Chassis - 8.1L, Chevy Express - 5.0L, 5.7L & 8.1L, Cutaway - 5.7L & 8.1L, Envoy, Envoy XL, Escalade, Escalade EXT, Jimmy Canadian, Montana, Rendezvous, RV Cutaway - 5.7L & 8.1L, S10 Pickup - 4.3L, Safari, Savana - 5.0L, 5.7L & 8.1L, Savana Camper Special - 5.7L & 8.1L, Savana Special - 5.7L & 8.1L, Sierra - 4.3L, 4.8L, 5.3L, 6.0L & 8.1L, Silhouette, Silverado - 4.3L, 4.8L, 5.3L, 6.0L & 8.1L, Sonoma - 4.3L, Suburban, Tahoe, Trailblazer, Venture, Yukon & Yukon XL)
- Off-Board Programming (Avalanche, Astro, Aztek, Blazer, Bravada, Cab & Chassis - 8.1L, Chevy Express - 5.0L, 5.7L & 8.1L, Cutaway - 5.7L & 8.1L, Envoy, Envoy XL, Escalade, Escalade EXT, Jimmy Canadian, Montana, Rendezvous, RV Cutaway - 5.7L & 8.1L, S10 Pickup - 4.3L, Safari, Savana - 5.0L, 5.7L & 8.1L, Savana Camper Special - 5.7L & 8.1L, Savana Special - 5.7L & 8.1L, Sierra - 4.3L, 4.8L, 5.3L, 6.0L & 8.1L, Silhouette, Silverado - 4.3L, 4.8L, 5.3L, 6.0L & 8.1L, Sonoma - 4.3L, Suburban, Tahoe, Trailblazer, Venture, Yukon & Yukon XL)
- PCM Programming (Cab & Chassis, Chevy Express, Cutaway, RV Cutaway, Savana, Savana Camper Special & Savana Special - 6.5L)
- Programming TDC Offset (Cab & Chassis, Chevy Express, Cutaway, RV Cutaway, Savana, Savana Camper Special & Savana Special - 6.5L)
- PCM Programming (S10 Pickup - 2.2L, Sonoma - 2.2L & Tracker)
- Theft Deterrent System Components
- 10-Minute Learn Procedure (Avalanche, Astro, Blazer, Cab & Chassis, Chevy Express, Cutaway, Escalade, Escalade EXT, Jimmy Canadian, RV Cutaway, S10 Pickup, Safari, Savana, Savana Camper Special & Savana Special, Sierra, Silverado, Sonoma, Suburban, Tahoe, Yukon & Yukon XL)
- 30-Minute Learn Procedure (Avalanche, Astro, Blazer, Cab & Chassis, Chevy Express, Cutaway, Escalade, Escalade EXT, Jimmy Canadian, RV Cutaway, S10 Pickup, Safari, Savana, Savana Camper Special & Savana Special, Sierra, Silverado, Sonoma, Suburban, Tahoe, Yukon & Yukon XL)
- Set Up a New Theft Deterrent Control Module (Aztek, Montana, Rendezvous, Silhouette & Venture)
- 10-Minute Learn Procedure (Aztek, Montana, Rendezvous, Silhouette & Venture)
- 30-Minute Learn Procedure (Aztek, Montana, Rendezvous, Silhouette & Venture)
- 10 Minute Learn Procedure With Standard Key (Bravada, Envoy, Envoy XL & Trailblazer)
- 30 Minute Learn Procedure With Standard Key (Bravada, Envoy, Envoy XL & Trailblazer)
- Procedure To Set Up New Theft Deterrent Control Module With Transponder Key (Bravada, Envoy, Envoy XL & Trailblazer)
- 10 Minute Re-Learn Procedure (Bravada, Envoy, Envoy XL & Trailblazer)
- Auto Learn Method (Vue)
- Saturn Service Stall Method (Vue)
- Throttle Body Relearn Procedure
- Jeep
- Drive Learn Procedure (Grand CHEROKEE & Liberty)
- Notes
- Procedure To Learn A Smooth 1st Neutral To Drive Shift
- Procedure To Learn A Smooth Neutral To Drive Garage Shift
- Procedure To Learn The 1st 2-3 Shift After A Restart Or Shift To Reverse
- Procedure To Learn A Smooth 2-3 & 3-4 Upshift
- Procedure To Learn A Smooth 4-3 Coastdown & Part Throttle 4-3 Kickdown
- Procedure To Learn A Smooth 1-2 Upshift & 3-2 Kickdown
- Procedure To Learn A Smooth Manual 2-1 Pulldown Shift As Well As A Neutral To Reverse Shift
- Procedure To Learn A Smooth Neutral To Reverse Shift
- Procedure To Learn A Smooth 4-5 Upshift for 545RFE
- Powertrain Control Module Programming
- Sentry Key Immobilizer Module Programming
- Programming Ignition Keys To Sentry Key Immobilizer Module
- Shift Quality Quick-Learn Procedure (Grand CHEROKEE & Liberty)
- Drive Learn Procedure (Grand CHEROKEE & Liberty)
- OBD-II Drive Cycles
- Driveline/Axles
- Drive Axle Noise Diagnosis - General Information
- Gear Tooth Contact Patterns - General Information
- Map - Drive Train & Transmission
- Drive Train & Transmission Systems
- Drivetrain And Transmission
- Notes
- Actuators (Electrical)
- Actuators (Vacuum)
- Automatic Transmission / Transaxle Assemblies/CVTS
- Automatic Transmission Fluid
- Axles
- Bearings And Races
- Bell Cranks
- Bell Housings
- Bushings (External)
- Cables (Speedometer)
- Cables (TV, Detent And Shift)
- Carrier Bearings
- Clutch Cables And Cable Housings
- Clutch Discs (Manual Transmissions)
- Clutch Forks
- Clutch Linkages (Mechanical)
- Clutch Master Cylinders
- Clutch Pedals
- Clutch Pivots
- Clutch Pressure Plates
- Clutch Release Bearings
- Clutch Slave Cylinders (Concentric)
- Clutch Slave Cylinders (Conventional Or External)
- Companion Flanges
- Connectors
- Cooler Bypass Valves
- Cooler Lines
- Coolers
- CV Joints
- Differential And Final Drive Assemblies
- Differential Fluid
- Dip Stick Tubes
- Dip Sticks (Fluid Level Indicators)
- Dowel Pins, Guides And Pilot Holes
- Drain Plugs And Gaskets
- Drive Shaft Flanges
- Drive Shafts And Half Shafts
- Dust Boots
- Engine Mounts
- Exciter Rings
- Filler Tubes
- Filters And Screens
- Flanges
- Flex Plates
- Fluid Level Indicators
- Fluids And Lubricants
- Flywheels
- Force Motors
- Gaskets
- Guides
- Half Shafts
- Hoses, Lines, And Tubes
- Housings (Bell, Case, Tail(Extension) And Auxiliary)
- Hydraulic Fluid
- Intermediate Shaft Support Bearings
- Key Interlock Systems
- Limited Slips
- Lines
- Linkages (External)
- Locking Hub Assemblies
- Locking Hub Control Knobs
- Lubricants
- Manual Transmission Fluid
- Manual Transmission/Transaxle Assemblies
- Metal Clad Seals
- METALASTIC Joints
- Modulator Pins
- Modulators
- Mounts (Engine, Transaxle And Transmission)
- Odometer Drives (Mechanical)
- Odometer Heads (Mechanical)
- Oil Pans
- Pans
- Pilot Holes
- Pressure Plates
- Pressure Switches
- Races
- Rubber Joints (METALASTIC)
- Screens
- Seals (Metal Clad)
- Seals
- Selector Interlock Systems
- Sensors
- Servos
- Shift Interlock Systems (Selector And Key Interlock Systems)
- Side Covers
- Slip Yokes
- Solenoids
- Speed Sensors (Electronic Wheel And Vehicle)
- Speedometer- Driven Gear Housing
- Speedometer/Odometer Drives (Mechanical)
- Speedometer/Odometer Heads (Mechanical)
- Speedometers/Odometers (Electronic)
- Switches
- Tone Wheels
- Toothed Rings (Tone Wheel)
- Torque Converters
- Transaxle Mounts
- Transducers (Transmission)
- Transfer Case Assemblies
- Transfer Case Fluid
- Transmission Coolers
- Transmission Mounts
- Transmission Pans
- Transmission Range Indicators (PRNDL)
- Tubes
- Universal Joints (CARDAN Or Cross Type)
- Vacuum Controls
- Vacuum Hoses
- Vacuum Motors
- Vacuum-Operated Switches
- Vehicle Speed Sensors
- Vents
- Vibration Dampers
- Wheel Attachment Hardware
- Wheel Speed Sensors
- Wiring Harnesses And Connectors
- Yokes And Slip Yokes
- Reason Code Explanation
- Automotive Terminology & Definitions
- Trouble Shooting - Clutches - General Information
- DTC Index - Coupe
- Electrical
- Map - Electrical Systems
- Electrical Systems
- Notes
- Map Standards Of Service
- The Map Process - Overview
- The Map Process - Overview Of Service Requirements And Suggestions
- Actuator Motors (Electric)
- Actuator Motors (Vacuum)
- Air Bags
- Alternators And Generators
- Amplifiers
- Antennas
- Batteries
- Battery Cables, Wires And Connectors
- Battery Cables
- Battery Trays And Hold Down Hardware
- Battery Wires
- Belts
- Bulb Sockets
- Bulbs, Sealed Beams And LEDS
- Cd Players
- Cigarette Lighter Assemblies
- Circuit Breakers
- Clutch Switches
- Connectors
- Control Modules
- Cruise Control Brake Switches
- Cruise Control Cables
- Cruise Control Clutch Switches
- Cruise Control Linkages And Cables
- Cruise Control Reservoirs
- Cruise Control Tubes
- Cruise Control Vacuum Dump Release Valves
- Cruise Control Vacuum Hoses, Tubes And
- Cruise Control Vehicle Speed Sensors
- Defoggers
- Defrosters
- Delays
- Dimmers
- Electric Heaters
- Equalizers
- Fuse Blocks
- Fuse Boxes And Blocks
- Fuses, Fusible Links And Circuit Breakers
- Fusible Links
- Gauges
- Generators
- Ground Cables And Straps
- Ground Straps
- Headlight Adjusters
- Heating Elements (Defrosters, Defoggers, Electric Heaters And Seats)
- Horns And Sirens
- Ignition Switches
- Indicator Lights
- Keyless Entry Keypads And Transmitters
- Keyless Entry Transmitters
- LEDS
- Lenses
- Microphones
- Mirrors (ELECTROCHROMATIC And Heated)
- Motors
- Neutral Safety Switches
- Odometers, Speedometers And Tachometers (Cable Driven)
- Odometers
- Power Distribution Center
- Pulleys
- Receivers, Amplifiers, Equalizers And Sub-Woofer Volume Controls
- Relay Boxes
- Relays
- Sealed Beams
- Seat Heaters
- Security Alarm Sensors
- Sirens
- Solenoids
- Speakers And Microphones
- Speedometer And Tachometer Linkages And Cables
- Speedometer Cables
- Speedometers
- Starters
- Sub-Woofer Volume Control
- Switches
- Tachometer Cables
- Tachometers
- Tape Players And Cd Players
- TENSIONERS
- Timers
- Transceivers
- Transducers
- Vacuum Accumulators (Reservoirs)
- Voltage Regulators
- Washer Fluid Level Senders
- Washer Pumps
- Wiper Arms And Blades
- Wiper Blades
- Wiper Hoses And Nozzles
- Wiper Linkages
- Wiper Nozzles
- Wiper Pump Reservoirs
- Wiring Harnesses And Connectors
- Battery, Starting & Charging System CHECKSHEET
- Reason Code Explanation
- Automotive Terminology & Definitions
- Electrical Systems
- Using lemon2025'S System Wiring Diagrams
- Map - Electrical Systems
- Engine
- Engine Overhaul Procedures - General Information
- * Please Read This First *
- Description
- Engine Identification
- Inspection Procedures
- Cleaning Procedures
- Component Cleaning
- Cylinder Head Replacement
- Cylinder Head Overhaul
- Pistons, Connecting Rods & Bearings
- Crankshaft & Main Bearings
- Camshaft
- Timing Chains & Belts
- Timing Gears
- Oil Pump
- Break-In Procedure
- General Cooling System Service - General Information
- Engine Overhaul Procedures - General Information
- Engine Performance
- Electrostatic Discharge Warning - General Information
- Engine Performance Diagnostic Routine Outline - General Information
- Engine Performance Safety Precautions
- Map - Engine Performance & Maintenance
- Engine Performance And Maintenance (Including Exhaust Systems)
- Engine Performance & Maintenance CHECKSHEET
- Engine Performance And Maintenance
- Notes
- Accelerator Pedal Position Sensor
- Accessory Belts
- Accessory Pulleys
- Air Conditioning Cycling Switches
- Air Conditioning Pressure Sensors
- Air Ducts And Tubes
- Air Filter Elements
- Air Filter Gaskets
- Air Filter Housings And Gaskets
- Air Fuel Ratio Sensors
- Air Injection Control Solenoids
- Air Plenums
- Air Pump Belts
- Air Pumps (Electric Driven)
- Air Tubes
- Aspirator, Check And DECEL Valves
- Baffles
- Ballast Primary Supply Resistor Wires
- Ballast Resistors And Primary Supply Resistors
- Barometric Pressure Sensors
- Batteries
- Battery Cables, Wires And Connectors
- Battery Connectors
- Battery Trays And Hold Down Hardware
- Battery Wires
- Belt Idler Assemblies (Accessory And Cam Belts)
- Belt TENSIONERS (Accessory And Cam Belt)
- Belt-Driven Air Pumps
- Boost Control Mechanism
- Camshaft Position Sensors
- Carburetors And Chokes
- Casting Core Plugs And Expansion Plugs
- Charge Air Coolers ""INTERCOOLERS"" (CAC)
- Check Valves
- Chemical Engine DECARBONIZATION
- Chokes
- Clutch Pedal Position Switches
- Cold Start Injectors
- Combustion Chamber Cleaning
- Connectors
- Coolant Recovery Tanks
- Coolant
- Cooling Fan Motor Modules
- Cooling Fan Motor Relays And Modules
- Cooling Fan Motor Resistors
- Cooling Fan Motor Sensors And Switches
- Cooling Fan Motor Switches
- Cooling Fan Motors
- Crankshaft Position Sensors
- Cylinder Deactivation Solenoid
- Cylinder Head Assemblies
- DECEL Valves
- Deflectors
- Dip Stick Tubes
- Dip Sticks And Tubes
- Distributor Advances And Retarders (Mechanical And Vacuum)
- Distributor Boots And Shields
- Distributor Caps
- Distributor Retarders (Mechanical And Vacuum)
- Distributor Rotors
- Distributor Shields
- Distributors
- Early Fuel Evaporation Valves (Heat Riser Assemblies)
- EGR Coolers
- EGR Exhaust Manifold Passages
- EGR Intake And Exhaust Manifold Passages
- EGR Plates And Coolers
- Electronic Spark Control Modules
- Electronic Transmission Control Devices
- Electronic Transmission Feedback Devices
- Engine Coolant Temperature Sensors
- Engine Cooling Systems
- Engine Covers (Oil Pan, Valve Cover, Timing Cover)
- Engine DECARBONIZATION
- Engine Oil Canisters
- Engine Oil Coolers (External)
- Engine Oil Drain Plugs And Gaskets
- Engine Oil Filters And Canisters
- Engine Oil Gaskets
- Engine Oil Pressure Gauges (Mechanical)
- Engine Oil
- Evaporative Emissions (EVAP) Canister Filters
- Evaporative Emissions (EVAP) Canister Purge Devices
- Evaporative Emissions (EVAP) Canisters
- Evaporative Emissions (EVAP) Feedback Devices
- Exhaust Gas RECIRCULATION Devices
- Exhaust Gas RECIRCULATION Feedback Devices
- Expansion Plugs
- Fan Control Sensor
- Fuel Accumulators And Dampers
- Fuel And Cold Start Injectors
- Fuel Caps
- Fuel Dampers
- Fuel Delivery Check Valves
- Fuel Distributors (BOSCH Cis)
- Fuel Filler Necks And RESTRICTORS
- Fuel Filters
- Fuel Injector Cleaning
- Fuel Injectors
- Fuel Level Senders
- Fuel Pressure Regulators
- Fuel Pumps (In-Tank, External, Electrical Or Mechanical)
- Fuel Rails
- Fuel RESTRICTORS
- Fuel System Cleaning Service
- Fuel Tanks
- Fuel
- Gaskets
- Grommets (Valve Cover)
- Harmonic Dampers
- Heater Control Valves
- Heater Cores
- Hose Clamps
- Hose Connectors
- Hose Couplers
- Hoses And Tube Couplers, Connectors And Clamps
- Hoses And Tubes (Fuel Lines, Radiator, Vacuum, By-Pass, Heater, Recovery Tank And Oil Coolers)
- Housings
- Idle Air Controls
- Idle Speed Control Actuators
- Ignition Boots
- Ignition Coil Towers
- Ignition Coils
- Ignition Control Modules (ICM)
- Ignition Switches
- Ignition Terminals
- Ignition Wires (Secondary)
- Inertia Fuel Shut-Off Switches
- Intake Air Temperature Sensors
- Intake Cleaning
- Intake Manifolds
- In-Tank Fuel Strainers
- INTERCOOLERS
- Knock Sensors
- Liquid Vapor Separators
- Long Block Assemblies
- Manifold Absolute Pressure (Map) Sensors
- Mass Air Flow (MAF) Sensors
- Metal Air Manifolds And Pipes
- Metal Air Pipes
- Mix Control Solenoids
- Motor Mounts
- O2 Sensors
- Oil Pans
- Oil Pressure Sending Units
- Oil Pump Pick-Up Screens
- Oil Pumps
- O-Rings, Gaskets, Seals And Spring Locks
- Park Neutral Position Switches
- PCV Breather Elements
- PCV Orifices
- PCV Valves
- Pick-Up Assemblies (Includes Magnetic, Hall Effect And Optical)
- Power Steering Pressure Sensors
- Powertrain Control Modules (Pcm) And Prom
- Powertrain Control Prom
- Pressurized Expansion Tank Caps
- Radiator / Cooling Fan Blades
- Radiator / Cooling Fan Clutches
- Radiator Caps And Pressurized Expansion Tank Caps
- Radiators
- Roll Over Valves
- Sealing Compounds
- Seals
- Secondary Air Injection System Management Devices
- Sensors
- Short Block Assemblies
- Shrouds, Baffles And Deflectors
- Spark Plugs
- Spring Locks
- Super Chargers
- Switches
- Thermal Vacuum Valves
- Thermostatic Air Door Assemblies
- Thermostats And Housings
- Throttle Bodies
- Throttle Body Cleaning
- Throttle Cables
- Throttle Linkages And Cables
- Throttle Position Sensors
- Throttle Position Switches
- Timing Belt Sprockets
- Timing Belts
- Timing Covers
- Torque Struts
- Transmission Range Switches
- Tube Clamps
- Tube Connectors
- Tube Couplers
- Tubes
- Turbo Chargers
- Vacuum Connections
- Vacuum Hoses, Tubes And Connections (Non-Metallic)
- Vacuum Regulator Solenoids
- Vacuum Tubes
- Valve Covers
- Vehicle Speed Senors
- Volume Air Flow Sensors
- Waste Gate And Boost Control Mechanisms
- Waste Gate Control Solenoids
- Water Pumps (Electric)
- Water Pumps (Non-Electric)
- Wiring Harnesses And Connectors
- Reason Code Explanation
- Automotive Terminology & Definitions
- Parasitic Load Explanation & Test Procedures - General Information
- State Emission Standards - Diesel
- State Emission Standards - Gas
- ALASKA
- ARIZONA
- CALIFORNIA
- Colorado
- CONNECTICUT
- DELAWARE
- District Of COLUMBIA
- GEORGIA
- IDAHO
- ILLINOIS
- INDIANA
- KENTUCKY
- MARYLAND
- MASSACHUSETTS
- MISSOURI
- NEVADA
- New Jersey
- New MEXICO
- New YORK
- North CAROLINA
- OHIO
- OREGON
- PENNSYLVANIA
- RHODE Island
- TENNESSEE
- TEXAS
- UTAH
- VIRGINIA
- WASHINGTON
- WISCONSIN
- U. S. EPA ASM2525 & ASM5015 Start-Up Emission Standards
- U. S. EPA Revised Final ASM Emission Standards (ASM5015 & ASM2525)
- U.S. EPA Im240 Emission Standards
- Waveforms - Injector Pattern Tutorial - General Information
- * Please Read This First *
- Purpose Of This Article
- Is A Lab Scope Necessary?
- The Two Types Of Injector Drivers
- The Two Ways Injector Circuits Are Wired
- Interpreting Injector Waveforms
- Current Waveform Samples
- Notes
- Example #1 - Voltage Controlled Driver
- Example #2 - Voltage Controlled Driver
- Example #3 - Voltage Controlled Driver
- Example #4 - Current Controlled Driver
- Example #5 - Current Controlled Driver
- Example #6 - Current Controlled Driver
- Example #7 - Current Controlled Driver
- Example #8 - Current Controlled Driver
- Voltage Waveform Samples
- Notes
- Example #1 - Voltage Controlled Driver
- Example #2 - Voltage Controlled Driver
- Example #3 - Voltage Controlled Driver
- Example #4 - Current Controlled Driver
- Example #5 - Current Controlled Driver
- Example #6 - Current Controlled Driver
- Example #7 - Current Controlled Driver
- Example #8 - Current Controlled Driver
- Map - Exhaust Systems
- Exhaust Systems
- Notes
- Map Standards Of Service
- The Map Process - Overview
- The Map Process - Overview Of Service Requirements And Suggestions
- Catalytic Converters
- Exhaust And Tail Pipes
- Exhaust Connections
- Hangers
- Heat Risers (Mechanical EFE Devices)
- Heat Shields
- Manifolds (Cast And Tube Type)
- Mechanical EFE Devices
- Muffler Valve
- Mufflers And Resonators
- Reason Code Explanation
- Exhaust Systems
- Heating, Ventilation & A/C (HVAC)
- Map - Heating, Ventilation, & Air Conditioning
- Heating, Ventilation & Air Conditioning Systems
- Notes
- Map Standards Of Service
- The Map Process - Overview
- The Map Process - Overview Of Service Requirements And Suggestions
- Accumulators
- Actuators (Electrical)
- Actuators (Vacuum)
- Air Conditioning Fittings
- Air Conditioning Hoses
- Air Conditioning Metal Lines
- Air Control Doors
- Air Dams (External)
- Air Distribution System
- Belts
- Blend Doors
- Blower Fans (Blower Wheel Or Squirrel Cage)
- Blower Motors
- Blower Resistors
- Blower Switches
- Cabin Air Filters
- Circuit Breakers
- Compressor Clutch Assemblies
- Compressors
- Condenser Air Seals
- Condenser Fan Motors
- Condensers
- Connectors
- Control Cables
- Control Heads (Function Selectors)
- Control Linkages
- Control Modules
- Coolant
- Cooling Fan Blades
- Cooling Fan Clutches
- Cooling Fan Motors
- Evaporator Drain Tubes
- Evaporator Filters
- Evaporator Pressure Regulators (EPRS)
- Evaporators
- Expansion Valves
- Function Selectors
- Fuses, Fusible Links And Circuit Breakers
- Fusible Links
- Gaskets
- Heater Cases
- Heater Control Valves
- Heater Cores
- Heater Hoses
- High Pressure Relief Valves (HPRV)
- Idlers
- In-Line Filters
- Metal Fittings
- Metal Lines
- Mix And Air Control Doors (Blend Doors)
- ORIFACE Tubes
- O-Rings
- Pilot-Operated Absolutes (POAS)
- Plenums
- Pressure Control Valves
- Pressure Sensors
- Pulleys
- Radiators
- Receiver-DRIERS
- Refrigerant Oil
- Refrigerant
- Relays
- Seals
- Service Ports
- Spring Lock Couplings
- Suction Throttling Valves (STVS)
- Switches (Electrical)
- TENSIONERS
- Thermistors And Pressure Sensors
- Thermostats And Housings
- Vacuum Hoses And Tubes
- Vacuum Reservoirs
- Vacuum Tubes
- Valves In Receiver (VIRS)
- Water Pumps (Electric Auxiliary)
- Wiring Harnesses And Connectors
- Heating, Ventilation & Air Conditioning System CHECKSHEET
- Reason Code Explanation
- Automotive Terminology & Definitions
- Heating, Ventilation & Air Conditioning Systems
- Map - Heating, Ventilation, & Air Conditioning
- Identification
- Metric Conversions
- OEM General Information
- Diagnostic Trouble Code Definitions - General Information
- How To Use The Engine Performance Section
- Maintenance Reminder Light (Reset Procedures)
- Emissions Maintenance Reminder (EGR)
- Emissions Maintenance Reminder (EMR Mileage)
- Emissions Maintenance Reminder (MAINT REQD Or Check EGR)
- Emissions Maintenance Reminder (Sri)
- Engine Oil Replacement Reminder
- Maintenance Service Reminder (ASSYST Maintenance Computer)
- Maintenance Service Reminder (Perform Service)
- Maintenance Service Reminder (Service Reminder Indicator)
- Maintenance Service Reminder (Service Reminder Message)
- Tire Pressure Monitor System Reminder
- Air Bag Restraints & SRS Components - Inspection & Replacement Tables
- Specifications Index
- Steering
- Map - Steering, Suspension, Wheel Alignment, Wheels & Tires
- Steering & Suspension Systems
- Wheel And Tire
- Steering & Suspension CHECKSHEET
- Wheels & Tires CHECKSHEET
- Steering And Suspension, Wheel Alignment, Wheels And Tires
- Notes
- Active Handling
- Active Suspension Control Modules
- Active Variable Ratio Steering
- Active Yaw Control
- Adaptive Cruise Control
- Advance TRAC
- Air Bags
- Air Ride Control Modules
- Air Ride Suspension Torsion Springs (Counter Balancing)
- Air Ride Suspension
- Air Ride Tubes
- Air Shocks And Air Struts
- Air Spring Valves
- Air Springs
- Air Suspension Control Valves
- Air Suspension DRIERS
- Axle Acceleration Sensor
- Ball Joints
- Body Acceleration Sensor
- Bushings
- Center Links
- Compressors
- Continuous Damping Control
- Control Arm Shafts
- Control Arms
- Control Modules
- Distance Regulation Control Module
- Distance Regulation Sensor
- Drag Links
- Dynamic Stability Control
- Dynamic Stability Traction Control
- Electronic Ride Control Shocks And Struts
- Electronic Stability Control
- Electronic Suspension System
- Flex Couplers
- Gaskets
- Height Sensors
- Hydraulic Hoses
- Hydraulic Power Steering Pumps
- Hydraulic Suspension Hoses
- Hydraulic Suspension Pumps
- Idler Arms
- Intermediate Shaft U-Joints
- King Pins
- Modules
- Pitman Arms
- Power Steering Belts
- Power Steering Coolers
- Power Steering Fluid
- Power Steering Hoses
- Power Steering Lines (Steel)
- Power Steering Pumps - Electric
- Power Steering Pumps
- Radar Sensor
- Radius Arms
- Relay Rods
- Relays
- Sensors
- Shock Absorbers, Strut Cartridges And Strut Assemblies
- Spindles
- Springs, Coil, Leaf And Torsion Bars
- STABILITRAC
- Stability Management System
- Steering Angle Sensor
- Steering Arms
- Steering Couplers
- Steering Dampers
- Steering Gears (Except Rack And Pinion)
- Steering Gears, Rack And Pinion
- Steering Knuckles
- Strike Out Bumpers
- Strut Bearing Plate Assemblies
- Strut Rods
- Suspension Pumps (Hydraulic)
- Sway Bar Links
- Sway Bar Mounting Bushings
- Sway Bars
- Switches
- Tie Rod Ends (Inner And Outer)
- Tire Pressure Monitoring System
- Tire Pressure Sensors
- Tires
- Torque Sensor
- Torsion Springs
- Track Bar Bushings
- Track Bars
- Trailing Arm Bushings
- Trailing Arms
- Valve Stems
- Vehicle Dynamics Control
- Vehicle Speed Sensor
- Vehicle Stability Assist
- Vehicle Stability/Skid Control
- Warning Lamps
- Wheel Alignment
- Wheel Attachment Hardware
- Wheel Bearings, Races And Seals
- Wheels (Rims)
- Wiring Harnesses And Connectors
- Reason Code Explanation
- Automotive Terminology & Definitions
- Wheel Alignment Theory & Operation - General Information
- Map - Steering, Suspension, Wheel Alignment, Wheels & Tires
- Traction Control Disable Procedures
- Trouble Shooting - Manual Transmission - General Information
- Heating, Ventilation & A/C (HVAC)
- A/C Compressor
- HVAC Systems - Compressor Servicing
- Ford FS-10 10-Cylinder
- Ford SC115 Scroll
- General Motors DELPHI-Thermal (HARRISON) CVC- 6/CVC-7, Hd6/Ht6/HU6, Hd6/Hr-6HE 6, V5 & V7.
- MITSUBISHI ASTT
- MITSUBISHI Scroll
- NIPPONDENSO 10-Cylinder
- NIPPONDENSO 10S15/10S17/10S20
- NIPPONDENSO 10PA17 10-Cylinder
- SANDEN Scroll
- SANDEN SD-7H15 7-Cylinder
- SANDEN TRS-90 Scroll
- SANDEN TRS-105 Scroll
- ZEXEL (SATURN - Variable Displacement Type)
- HVAC Systems - Compressor Servicing
- General Servicing
- Cabin Air Filter (Special Applications) - General Information
- HVAC Systems - Compressor Servicing
- Ford FS-10 10-Cylinder
- Ford SC115 Scroll
- General Motors DELPHI-Thermal (HARRISON) CVC- 6/CVC-7, Hd6/Ht6/HU6, Hd6/Hr-6HE 6, V5 & V7.
- MITSUBISHI ASTT
- MITSUBISHI Scroll
- NIPPONDENSO 10-Cylinder
- NIPPONDENSO 10S15/10S17/10S20
- NIPPONDENSO 10PA17 10-Cylinder
- SANDEN Scroll
- SANDEN SD-7H15 7-Cylinder
- SANDEN TRS-90 Scroll
- SANDEN TRS-105 Scroll
- ZEXEL (SATURN - Variable Displacement Type)
- HVAC Systems - General Servicing
- HVAC Control Systems
- HVAC Systems - Compressor Servicing
- Ford FS-10 10-Cylinder
- Ford SC115 Scroll
- General Motors DELPHI-Thermal (HARRISON) CVC- 6/CVC-7, Hd6/Ht6/HU6, Hd6/Hr-6HE 6, V5 & V7.
- MITSUBISHI ASTT
- MITSUBISHI Scroll
- NIPPONDENSO 10-Cylinder
- NIPPONDENSO 10S15/10S17/10S20
- NIPPONDENSO 10PA17 10-Cylinder
- SANDEN Scroll
- SANDEN SD-7H15 7-Cylinder
- SANDEN TRS-90 Scroll
- SANDEN TRS-105 Scroll
- ZEXEL (SATURN - Variable Displacement Type)
- HVAC Systems - General Servicing
- Manual HVAC Systems - Coupe
- Model Identification
- Specifications
- Description & Operation
- Component Locations
- Troubleshooting
- Performance Tests
- System Tests
- Symptom Tests
- Notes
- Test A: When The Ignition Switch Is "On", The A/C Does Not Operate
- Test B: When The Air Outlet Changeover Control Knob Is Moved To Defroster Or Defroster/Foot Position, The A/C Or The Inside/Outside Changeover Damper Motor Does Not Operate
- Test C: When The A/C Is Operating, Temperature Inside The Passenger Compartment Does Not Decrease (Cool Air Is Not Emitted)
- Test D: Blower Fan And Motor Does Not Turn
- Test E: Blower Fan And Motor Does Not Stop Turning
- Test F: When The A/C Is Operating Condenser Fan Or Radiator Fan Does Not Turn
- Test G: The A/C Indicator Flashes (Vehicle With 3.0L Engine)
- Component Tests
- Removal & Installation
- Torque Specifications
- Wiring Diagrams
- HVAC Systems - Compressor Servicing
- A/C Compressor
- Maintenance
- Maintenance Reminder Light (Reset Procedures)
- Emissions Maintenance Reminder (EGR)
- Emissions Maintenance Reminder (EMR Mileage)
- Emissions Maintenance Reminder (MAINT REQD Or Check EGR)
- Emissions Maintenance Reminder (Sri)
- Engine Oil Replacement Reminder
- Maintenance Service Reminder (ASSYST Maintenance Computer)
- Maintenance Service Reminder (Perform Service)
- Maintenance Service Reminder (Service Reminder Indicator)
- Maintenance Service Reminder (Service Reminder Message)
- Tire Pressure Monitor System Reminder
- Maintenance Reminder Light (Reset Procedures)
- Restraints
- Air Bag, SRS
- Air Bag Restraint Systems - Coupe
- Description & Operation
- Component Locations
- Servicing
- System Operation Check
- Air Bag Safety Precautions
- Adjustments
- Disabling & Activating Air Bag System
- Disposal Procedures
- Post-Collision Inspection
- Removal & Installation
- Diagnostics
- Diagnostic Tests
- Code 14: Analog "G" Sensor
- Code 15 & 16: SAFING "G" Sensor
- Code21, 22, 61 & 62: Driver-Side Air Bag Module
- Code 24, 25, 64 & 65: Passenger-Side Air Bag Module
- Code 31 & 32: SRS-Ecu Capacitor System
- Code 34: Connector Lock System
- Code 35: SRS-Ecu (After Air Bag Deployment)
- Code 41 & 42: IG1 Power Circuit
- Code 43 & 44: Air Bag Warning Light Does Not Light Or Will Not Turn Off
- Code 45: SRS-Ecu Non-Volatile Memory & A/D Converter System
- Code 51 & 52: Driver-Side Air Bag Module
- Code 54 & 55: Passenger-Side Air Bag Module
- Vehicle Communications
- Wire Repair
- Torque Specifications
- Wiring Diagrams
- Air Bag Restraint Systems - Coupe
- Air Bag, SRS
- Steering
- Manual Steering
- Steering System - Coupe
- General Description
- Power Steering Diagnosis
- Introduction
- Troubleshooting Strategy
- Symptom Chart
- Symptom Procedures
- INSPECTION PROCEDURE 1: Excessive Play Of Steering Wheel
- INSPECTION PROCEDURE 2: Difficult Steering Wheel Operation (Insufficient Power Assist)
- INSPECTION PROCEDURE 3: Rattling Noise
- INSPECTION PROCEDURE 4: Shrill Noise
- INSPECTION PROCEDURE 5: Squealing Noise
- INSPECTION PROCEDURE 6: Hissing Noise
- INSPECTION PROCEDURE 7: Droning Noise
- INSPECTION PROCEDURE 8: Squeaking Noise
- INSPECTION PROCEDURE 9: Vibration
- INSPECTION PROCEDURE 10: Oil Leakage From Hose Connection
- INSPECTION PROCEDURE 11: Oil Leakage From Hose Assembly
- INSPECTION PROCEDURE 12: Oil Leakage From Oil Reservoir
- INSPECTION PROCEDURE 13: Oil Leakage From Oil Pump
- INSPECTION PROCEDURE 14: Oil Leakage From Gear Box
- Special Tools
- On-Vehicle Service
- Steering Wheel Free Play Check
- Steering Angle Check
- Tie Rod End Ball Joint Breakaway Torque Check
- Stationary Steering Effort Check
- Steering Wheel Return To Center Check
- Drive Belt Tension Check
- Fluid Level Check
- Fluid Replacement
- Power Steering System Bleeding
- Oil Pump Pressure Test
- Power Steering Pressure Switch Check
- Ball Joint Dust Cover Inspection
- Steering Wheel And Shaft Assembly
- Power Steering Gear Box Assembly
- Removal And Installation
- Inspection
- Disassembly And Assembly
- Notes
- Lubrication And Sealing Points
- Disassembly Service Points
- << A >> Tie Rod/Tab Washer Removal
- << B >> Rack Support Cover Removal
- << C >> Oil Seal/Pinion And Valve Assembly
- << D >> Seal Ring Removal
- << E >> Ball Bearing/Oil Seal Removal
- << F >> CIRCLIP Removal
- << G >> Rack Removal
- << H >> Oil Seal Removal
- << I >> Ball Bearing Removal
- << J >> Needle Roller Bearing Removal
- << K >> Oil Seal Removal
- Assembly Service Point
- >>A<< Oil Seal Installation
- >>B<< Needle Roller Bearing/Ball Bearing
- >>C<< Oil Seal/O-Ring Installation
- >>D<< Rack Installation
- >>E<< Rack Bushing Installation
- >>F<< CIRCLIP Installation
- >>G<< Oil Seal/Ball Bearing Installation
- >>H<< Seal Ring Installation
- >>I<< Oil Seal Installation
- >>J<< End Plug Installation
- >>K<< Rack Support Cover/Jam Nut Installation
- >>L<< Total Pinion Torque Adjustment
- >>M<< Tab Washer/Tie Rod Installation
- >>N<< Bellows Band Installation
- >>O<< Tie Rod End/Tie Rod End Jam Nut
- Tie Rod End Ball Joint Dust Cover Replacement
- Power Steering Oil Pump Assembly
- Power Steering Hoses
- Ignition Switch
- Specifications
- Steering System - Coupe
- Power Steering
- Steering System - Coupe
- General Description
- Power Steering Diagnosis
- Introduction
- Troubleshooting Strategy
- Symptom Chart
- Symptom Procedures
- INSPECTION PROCEDURE 1: Excessive Play Of Steering Wheel
- INSPECTION PROCEDURE 2: Difficult Steering Wheel Operation (Insufficient Power Assist)
- INSPECTION PROCEDURE 3: Rattling Noise
- INSPECTION PROCEDURE 4: Shrill Noise
- INSPECTION PROCEDURE 5: Squealing Noise
- INSPECTION PROCEDURE 6: Hissing Noise
- INSPECTION PROCEDURE 7: Droning Noise
- INSPECTION PROCEDURE 8: Squeaking Noise
- INSPECTION PROCEDURE 9: Vibration
- INSPECTION PROCEDURE 10: Oil Leakage From Hose Connection
- INSPECTION PROCEDURE 11: Oil Leakage From Hose Assembly
- INSPECTION PROCEDURE 12: Oil Leakage From Oil Reservoir
- INSPECTION PROCEDURE 13: Oil Leakage From Oil Pump
- INSPECTION PROCEDURE 14: Oil Leakage From Gear Box
- Special Tools
- On-Vehicle Service
- Steering Wheel Free Play Check
- Steering Angle Check
- Tie Rod End Ball Joint Breakaway Torque Check
- Stationary Steering Effort Check
- Steering Wheel Return To Center Check
- Drive Belt Tension Check
- Fluid Level Check
- Fluid Replacement
- Power Steering System Bleeding
- Oil Pump Pressure Test
- Power Steering Pressure Switch Check
- Ball Joint Dust Cover Inspection
- Steering Wheel And Shaft Assembly
- Power Steering Gear Box Assembly
- Removal And Installation
- Inspection
- Disassembly And Assembly
- Notes
- Lubrication And Sealing Points
- Disassembly Service Points
- << A >> Tie Rod/Tab Washer Removal
- << B >> Rack Support Cover Removal
- << C >> Oil Seal/Pinion And Valve Assembly
- << D >> Seal Ring Removal
- << E >> Ball Bearing/Oil Seal Removal
- << F >> CIRCLIP Removal
- << G >> Rack Removal
- << H >> Oil Seal Removal
- << I >> Ball Bearing Removal
- << J >> Needle Roller Bearing Removal
- << K >> Oil Seal Removal
- Assembly Service Point
- >>A<< Oil Seal Installation
- >>B<< Needle Roller Bearing/Ball Bearing
- >>C<< Oil Seal/O-Ring Installation
- >>D<< Rack Installation
- >>E<< Rack Bushing Installation
- >>F<< CIRCLIP Installation
- >>G<< Oil Seal/Ball Bearing Installation
- >>H<< Seal Ring Installation
- >>I<< Oil Seal Installation
- >>J<< End Plug Installation
- >>K<< Rack Support Cover/Jam Nut Installation
- >>L<< Total Pinion Torque Adjustment
- >>M<< Tab Washer/Tie Rod Installation
- >>N<< Bellows Band Installation
- >>O<< Tie Rod End/Tie Rod End Jam Nut
- Tie Rod End Ball Joint Dust Cover Replacement
- Power Steering Oil Pump Assembly
- Power Steering Hoses
- Ignition Switch
- Specifications
- Steering System - Coupe
- Manual Steering
- Suspension
- Front Suspension - Coupe
- Rear Suspension - Coupe
- General Description
- Rear Suspension Diagnosis
- Special Tools
- On-Vehicle Service
- Rear Suspension Assembly
- Upper Arm Assembly
- Trailing Arm Assembly
- Lower Arm And Toe Control Arm Assembly
- Shock Absorber Assembly
- Stabilizer Bar
- Specifications
- Wheel Alignment Specifications & Adjustment Procedures - Coupe
- Transmission
- Clutch - Coupe
- Manual Trans
- Manual Transmission - Servicing
- Manual Transmissions - Coupe
- General Description
- Manual Transaxle Diagnosis
- Special Tools
- On-Vehicle Service
- Transaxle Control
- Shift Lever Assembly
- Transaxle Assembly
- Removal And Installation
- <2.4L Engine>
- Required Special Tools:
- <3.0L Engine>
- Removal Service Points
- << A >> Starter Motor Removal
- << B >> Clutch Release Cylinder Removal
- << C >> CENTERMEMBER Assembly Removal
- << D >> Transaxle Mount Bracket Removal
- Tie Rod End/Lower Arm Ball Joint Disconnection
- << F >> Clutch Release Bearing Disengagement
- << G >> Drive Shaft/Drive Shaft And Inner Shaft Disconnection
- << H >> Transaxle Assembly Removal
- Installation Service Points
- Removal And Installation
- Specifications
- General Information
- Transaxle
- Disassembly And Assembly
- < F5M42 >
- < F5M51 >
- Disassembly Service Points
- << A >> Sealing Cap Removal
- << B >> Transaxle Case Removal
- << C >> Spring Pin Removal
- << D >> 3RD-4TH Speed Shift Rail/3RD-4TH Speed Shift Fork/5TH Speed-Reverse Shift Rail/5TH Speed-Reverse Shift Fork Removal
- << E >> 3RD-4TH Speed Shift Rail/3RD-4TH Speed Shift Fork/5TH-Reverse Speed Shift Rail/5TH-Reverse Speed Shift Fork Removal
- << F >> Input Shaft And Output Shaft Removal
- << G >> Differential Removal
- Adjustment Before Assembly
- Assembly Service Points
- << A >> Output Shaft/Input Shaft Installation
- << B >> Input Shaft/Output Shaft/Differential Installation
- << C >> 5TH Speed-Reverse Shift Fork/5TH Speed-Reverse Shift Rail/3RD-4TH Speed Shift Fork/3RD-4TH Speed Shift Rail Installation
- << D >> 5TH-Reverse Speed Shift Fork/5TH-Reverse Speed Shift Rail/3RD-4TH Speed Shift Fork/3RD-4TH Speed Shift Rail Installation
- << E >> Spring Pin Installation
- << F >> Spacer And Outer Race Installation
- << G >> Transaxle Case Installation
- << H >> Transaxle Case Installation
- << I >> Sealing Cap Installation
- << J >> Under Cover Installation
- << K >> Control Housing Installation
- << L >> Speedometer Gear Installation
- << M >> Select Lever Installation
- Inspection
- Disassembly And Assembly
- Input Shaft
- Disassembly And Assembly
- < F5M42 >
- < F5M51 >
- Disassembly Service Points
- Assembly Service Points
- << A >> Oil Seal Installation
- << B >> Ball Bearing Installation
- << C >> Snap Ring Installation
- << D >> Synchronizer Spring Installation
- ><< E >> Synchronizer Ring Installation
- << F >>3RD-4TH Speed Synchronizer Hub Installation
- << G >> Synchronizer Sleeve Installation
- << H >> 4TH Speed Gear Sleeve Installation
- << I >> a5TH SPEED GEAR INSTALLATION
- << J >> Thrust Plate Installation
- << K >> Thrust Plate Stopper Installation
- << L >> Ball Bearing Installation
- << M >> Snap Ring Installation
- Inspection
- Disassembly And Assembly
- Output Shaft
- Disassembly And Assembly
- < F5M42 >
- < F5M51 >
- Disassembly Service Points
- << A >> Ball Bearing Removal
- << B >> Taper Roller Bearing Removal
- << C >> Reverse Gear Bearing Sleeve Removal
- << D >> 5TH Speed-Reverse Synchronizer Hub Removal
- << E >> 3RD Speed Gear Removal
- << F >> 2ND Speed Gear Sleeve Removal
- << G >> 1ST Speed Gear Sleeve Removal
- << H >> Roller Bearing Inner Race Removal
- << I >> Taper Roller Bearing Removal
- Assembly Service Points
- << A >> Oil Seal Installation
- << B >> Roller Bearing Inner Race Installation
- << C >> Taper Roller Bearing Installation
- << D >> Snap Ring Installation
- << E >> 1ST Speed Gear Sleeve Installation
- << F >> Synchronizer Spring Installation
- << G >> 1ST-2ND Speed Synchronizer Hub Installation
- << H >> Synchronizer Sleeve Installation
- << I >> 2ND Speed Gear Sleeve Installation
- << J >> 3RD Speed Gear Installation
- << K >> Snap Ring Installation
- << L >> 4TH Speed Gear Installation
- << M >>5TH Speed Gear Sleeve Installation
- << N >> Synchronizer Spring Installation
- << O >> Synchronizer Ring Installation
- << P >> 5TH Speed-Reverse Synchronizer Hub Installation
- << Q >> Reverse Gear Sleeve Installation
- << R >> Ball Bearing Installation
- << S >> Taper Roller Bearing Installation
- << T >> Snap Ring Installation
- Inspection
- Disassembly And Assembly
- Reverse Idler Gear
- Speedometer Gear
- Select Lever
- Control Housing
- Clutch Housing
- Transmission Case
- Differential
- External Pages