Technical Service Bulletins: Other Variant
WARNING: This page is about the 240 Base, 4D Sedan, Automatic, AW70, which is a different variant/trim than selected.
- A/C Compressor
- Accessories & Equipment
- Accessories Control Systems
- Control Module Swapping (TJ 31946.1.2)
- MIDTRONICS PSC-550 Vehicle Power Supply Use Required During Software Download. Includes Mobile Technician Program (30-04)
- Use Of Electrical Surge Arrestors When Arc Welding (GROUP 81, NO. 209)
- OBD System Memory Cassette For VOLVO Scan Tool (VST) (GROUP 28, NO. 111)
- Air Bag, SRS
- R10058/R10125/R10136 Driver Airbag Returns - Shipping Instruction (SMB88-010)
- R10058 Driver Airbag Returns - Shipping Instruction (PB88-010)
- Used Airbag Return/Disposal Pilot Program (SMB88-026)
- Extended Service Life For Airbags (SRS) (GROUP 88, NO. 0002)
- SRS Test Tools - New Tool Info/Ordering Information (GROUP 00, NO. 38)
- Clean Up After An Airbag Has Deployed (GROUP 88, NO. 207)
- Drilling Out Airbag Screw In The Steering Wheel-Info (GROUP 88, NO. 205)
- Service Manual Correction - SRS Wiring Text (GROUP 88, NO. 105)
- Anti-Lock Brakes
- Anti-Theft Systems
- Automatic Trans
- Mandatory VOLVO Special Tool List (ST-001-2020)
- Mandatory VOLVO Special Tool List (ST-001-2021)
- Retailer Technical Journal 16724 Coolant Contamination In Automatic Transmissions (43-48)
- Automatic Transmission Cooler/Lines Flushing (43-56)
- Automatic Transmission Diagnostic Sheet (43-08)
- Transmission And AWD Lubricants (40-04)
- Installation Of Pinion Seal (GROUP 46, NO. 204)
- Safety Instructions For FLUOROELASTOMER Seals (GROUP 10, NO. 201/701)
- Auxiliary Emission Control Systems
- Oxygen Sensor Thread Repair Method (TJ 35818.1.1)
- E-Prom Installation Equipment (GROUP 00, NO. 108)
- MFI LH2.4 E Prom Exchange For Cold Start Symptoms (GROUP 28, NO. 102X)
- Engine Management Systems And Control Modules (GROUP 28, NO. 206)
- New EPROM Kit - Service Manual Revision (GROUP 28, NO. 920)
- Use Of Electrical Surge Arrestors When Arc Welding (GROUP 81, NO. 209)
- Service Manual Correction: Lighting Ref. 31486/1 (GROUP 38, NO. 204X)
- Technical Service Literature Update 48 - Engine MGMT (TSLU 48)
- Cold Start Symptoms/Poor Fuel-New Prom (REGINA/REX) (GROUP 28, NO. 113)
- Cold Start DRIVEABILITY Problem - Control Module (GROUP 28, NO. 112)
- Protection For Engine Management Connectors (GROUP 28, NO. 205/906)
- OBD System Memory Cassette For VOLVO Scan Tool (VST) (GROUP 28, NO. 111)
- New EZ-116K Impulse Sender/Specification (GROUP 28, NO. 104)
- Axle Shafts
- Body Interior
- Control Module Swapping (TJ 31946.1.2)
- DTC 1-4-4 In Ignition Control Module - Manual Update (GROUP 28, NO. 212X)
- New Cable Terminal As A Replacement Part (GROUP 37, NO. 207)
- Use Of Electrical Surge Arrestors When Arc Welding (GROUP 81, NO. 209)
- OBD System Memory Cassette For VOLVO Scan Tool (VST) (GROUP 28, NO. 111)
- Brakes Control Systems
- Charging Systems
- Clutch
- Communication Devices
- Cooling System (Mechanical)
- New Steel Cylinder Head Gasket (GROUP 21, NO. 213)
- Installation Of Temperature Control For Coolant Fan (GROUP 26, NO. 205)
- Replacement Of Mounting For Engine Cooling Fan (GROUP 26, NO. 206)
- New Camshaft/Intermediate Shaft Seal & Install Tool (GROUP 21, NO. 121)
- Installation Of Cooling Thermostat - Procedure (GROUP 26, NO. 204/910)
- Safety Instructions For FLUOROELASTOMER Seals (GROUP 10, NO. 201/701)
- Gasoline Eng P20 - New Fuel Pump Wiring Harness (GROUP 23, NO. 121)
- Cruise Control Systems
- Differentials & Drive Axles
- Driveshaft & Universal Joints
- Engine Control Systems
- Control Module Swapping (TJ 31946.1.2)
- Pressure Washing Engines (TJ21507)
- MIDTRONICS PSC-550 Vehicle Power Supply Use Required During Software Download. Includes Mobile Technician Program (30-04)
- E-Prom Installation Equipment (GROUP 00, NO. 108)
- MFI LH2.4 E Prom Exchange For Cold Start Symptoms (GROUP 28, NO. 102X)
- Engine Management Systems And Control Modules (GROUP 28, NO. 206)
- New EPROM Kit - Service Manual Revision (GROUP 28, NO. 920)
- Use Of Electrical Surge Arrestors When Arc Welding (GROUP 81, NO. 209)
- Service Manual Correction: Lighting Ref. 31486/1 (GROUP 38, NO. 204X)
- Technical Service Literature Update 48 - Engine MGMT (TSLU 48)
- Cold Start Symptoms/Poor Fuel-New Prom (REGINA/REX) (GROUP 28, NO. 113)
- Cold Start DRIVEABILITY Problem - Control Module (GROUP 28, NO. 112)
- Protection For Engine Management Connectors (GROUP 28, NO. 205/906)
- OBD System Memory Cassette For VOLVO Scan Tool (VST) (GROUP 28, NO. 111)
- New EZ-116K Impulse Sender/Specification (GROUP 28, NO. 104)
- Entertainment Systems
- Exhaust
- Exterior Body Panels
- Exterior Lights
- Frames, Subframes & Crossmembers
- Front Suspension
- Mandatory VOLVO Special Tool List (ST-001-2020)
- Mandatory VOLVO Special Tool List (ST-001-2021)
- New Bushing Press Tools/Supplier Information (GROUP 00, NO. 96)
- Replacing Trailing Arm Bushing (GROUP 65, NO. 203)
- Service Campaign - Sway Bar Bushing Replacement (GROUP 76, NO. 105)
- Service Manual Correction - Tie Rod End Torque (GROUP 17, NO. 108)
- Fuel System
- Fuses & Circuit Breakers
- DTC 1-4-4 In Ignition Control Module - Manual Update (GROUP 28, NO. 212X)
- New Cable Terminal As A Replacement Part (GROUP 37, NO. 207)
- Use Of Electrical Surge Arrestors When Arc Welding (GROUP 81, NO. 209)
- Measurement Of Voltage Drop Across Ground Connection (GROUP 37, NO. 204)
- New Sealed Crimping Sleeve For Wiring Connections (GROUP 37, NO. 701)
- More New Car Features (GROUP 00, NO. 203)
- Service Manual Correction - SRS Wiring Text (GROUP 88, NO. 105)
- Gauges & Instrument Panels
- Hazardous Waste Material
- Headlights
- HVAC Control Systems
- Retailer Technical Journal 19292 Climate Control System, Cleaning (TJ 19292)
- Replacing Pulley & Magnetic Clutch On A/C Compressor (GROUP 87, NO. 214)
- New A/C Compressor Tools Descriptions (GROUP 00, NO. 103)
- Conversion Of A/C System From R12 To R134A Retrofit (GROUP 87, NO. 217)
- Cleaning The Heater Unit Drainage Hose (GROUP 87, NO. 219)
- New Heater Control Valve For Climate Control System (GROUP 87, NO. 211)
- More New Car Features (GROUP 00, NO. 203)
- New Climate Control, Evaporator Replacement (GROUP 87, NO. 206)
- Identification
- Expendable Items Parts List (SMB00-108D)
- New Shipping Address And Label (SMB00-012)
- VIN Plate And VIN Specific Labeling Ordering Procedure (SMB89-005)
- VOLVO Model Designations (00-20.A)
- Extended Service Life For Airbags (SRS) (GROUP 88, NO. 0002)
- Odometer Replacement - Information Sticker (GROUP 38, NO. 114)
- Ignition System
- Infotainment
- Interior/Exterior Trim
- Interior/Illumination Lights
- Lubrication System
- Oil Consumption Test (TJ 35526.1.6)
- Expendable Items Parts List (SMB00-108D)
- Engine Oil Consumption Test FAQ (SMB22-006)
- Recommended Engine Oils (GROUP 22, NO. 3)
- New Steel Cylinder Head Gasket (GROUP 21, NO. 213)
- New Camshaft/Intermediate Shaft Seal & Install Tool (GROUP 21, NO. 121)
- Discolored Engine Oil (GROUP 22, NO. 105)
- Identification Of Abnormal Oil Consumption (GROUP 22, NO. 107)
- Safety Instructions For FLUOROELASTOMER Seals (GROUP 10, NO. 201/701)
- Service Manual Correction - Oil Change Interval (GROUP 17, NO. 107)
- Gasoline Eng P20 - New Fuel Pump Wiring Harness (GROUP 23, NO. 121)
- Manual Steering
- Manual Trans
- Transmission And AWD Lubricants (40-04)
- Installation Of Pinion Seal (GROUP 46, NO. 204)
- Safety Instructions For FLUOROELASTOMER Seals (GROUP 10, NO. 201/701)
- More New Car Features (GROUP 00, NO. 203)
- Improved Reverse Shift Quality Modifications (GROUP 43, NO. 116)
- Manual Trans. Rebuilding Quality - Longer Dog-Keys (GROUP 43, NO. 115)
- Manual Trans. - New Driven Plates & Release Bearing (GROUP 41, NO. 105)
- Mechanical
- VOLVO Engine Oil Consumption (SMB22-007)
- Mandatory VOLVO Special Tool List (ST-001-2020)
- Mandatory VOLVO Special Tool List (ST-001-2021)
- Pressure Washing Engines (TJ21507)
- New Steel Cylinder Head Gasket (GROUP 21, NO. 213)
- Replacement Of Mounting For Engine Cooling Fan (GROUP 26, NO. 206)
- Timing Belt Replacement Interval Tables (11/94-01)
- New Camshaft/Intermediate Shaft Seal & Install Tool (GROUP 21, NO. 121)
- Replacement Of Press Bolts On TWC Converter - Info (GROUP 25, NO. 207/912)
- Identification Of Abnormal Oil Consumption (GROUP 22, NO. 107)
- Piston Clearance In Used Engines - Inspection/Specs. (GROUP 21, NO. 209/718)
- Safety Instructions For FLUOROELASTOMER Seals (GROUP 10, NO. 201/701)
- Damage To Carrier Plate Impulse Wheel (GROUP 21, NO. 208/715)
- Fuel Pump Noise - Pressure Damper (GROUP 23, NO. 130)
- Gasoline Eng P20 - New Fuel Pump Wiring Harness (GROUP 23, NO. 121)
- Mechanical - Hydraulic
- Memory Modules
- Mirrors
- Paint & Coatings
- Passive Restraints
- Procedures
- Data Requests From Lea (Police) And/Or Customers (TJ 28941.5.0)
- VOLVO Wheel Repair Guidelines (SMB77-008)
- High Voltage (HV) Module Balancer Cart (ST-251)
- VIDA Updated Graphical Plotter Functionality Applications - VIDA (SJ1000785)
- Mandatory VOLVO Special Tool List (ST-001-2020)
- Mandatory VOLVO Special Tool List (ST-001-2021)
- Newsletter 105: Mandatory Tools (ST-237)
- Recall Compliance Clearance Letter Requests (SMB00-440)
- GDPR - Information Notice (SPJ34864.2.0)
- Rear Suspension
- Mandatory VOLVO Special Tool List (ST-001-2020)
- Mandatory VOLVO Special Tool List (ST-001-2021)
- New Bushing Press Tools/Supplier Information (GROUP 00, NO. 96)
- Replacing Trailing Arm Bushing (GROUP 65, NO. 203)
- Service Campaign - Sway Bar Bushing Replacement (GROUP 76, NO. 105)
- Service Manual Correction - Tie Rod End Torque (GROUP 17, NO. 108)
- Restraints Control Systems
- Seats
- Interior Seat Protection Kit (SMB85-002)
- Seat Belt Extender Availability (GROUP 88, NO. 1A)
- DTC 1-4-4 In Ignition Control Module - Manual Update (GROUP 28, NO. 212X)
- Power Antenna Malfunction (GROUP 39, NO. 212/932)
- Seat Heater Installation - Procedure (GROUP 85, NO. 116)
- More New Car Features (GROUP 00, NO. 203)
- Starter
- Steering Column
- Steering Control Systems
- Steering Gear
- Sun Roof/T-Top/Convertible Top
- Suspension Control Systems
- System
- Control Module Swapping (TJ 31946.1.2)
- Pressure Washing Engines (TJ21507)
- VCT 2000 (9511500 And 9511540) And Cable 9511535 Troubleshooting, Firmware Upgrade, VCT 2000 Recovery (30-05)
- E-Prom Installation Equipment (GROUP 00, NO. 108)
- MFI LH2.4 E Prom Exchange For Cold Start Symptoms (GROUP 28, NO. 102X)
- Engine Management Systems And Control Modules (GROUP 28, NO. 206)
- New EPROM Kit - Service Manual Revision (GROUP 28, NO. 920)
- New Steel Cylinder Head Gasket (GROUP 21, NO. 213)
- Use Of Electrical Surge Arrestors When Arc Welding (GROUP 81, NO. 209)
- Service Manual Correction: Lighting Ref. 31486/1 (GROUP 38, NO. 204X)
- Technical Service Literature Update 48 - Engine MGMT (TSLU 48)
- New Camshaft/Intermediate Shaft Seal & Install Tool (GROUP 21, NO. 121)
- Cold Start Symptoms/Poor Fuel-New Prom (REGINA/REX) (GROUP 28, NO. 113)
- Cold Start DRIVEABILITY Problem - Control Module (GROUP 28, NO. 112)
- Protection For Engine Management Connectors (GROUP 28, NO. 205/906)
- OBD System Memory Cassette For VOLVO Scan Tool (VST) (GROUP 28, NO. 111)
- Ignition System Replacement (GROUP 37, NO. 11)
- Safety Instructions For FLUOROELASTOMER Seals (GROUP 10, NO. 201/701)
- Damage To Carrier Plate Impulse Wheel (GROUP 21, NO. 208/715)
- More New Car Features (GROUP 00, NO. 203)
- New EZ-116K Impulse Sender/Specification (GROUP 28, NO. 104)
- Gasoline Eng P20 - New Fuel Pump Wiring Harness (GROUP 23, NO. 121)
- Transfer Case
- Transmission Control Systems
- Control Module Swapping (TJ 31946.1.2)
- MIDTRONICS PSC-550 Vehicle Power Supply Use Required During Software Download. Includes Mobile Technician Program (30-04)
- Use Of Electrical Surge Arrestors When Arc Welding (GROUP 81, NO. 209)
- OBD System Memory Cassette For VOLVO Scan Tool (VST) (GROUP 28, NO. 111)
- Warning Systems
- Wheel Alignment
- Wheels & Tire System
- Window Motors & Regulators
- Windshield Cleaning (SMB00-444)
- Windshield POWERCURE Dispenser And Adhesive (SMB84-001)
- PUR Bonded Windows, New Adhesive Kit (84-0033)
- Windshield Replacement With PUR Bonded Windshield (GROUP 84, NO. 204)
- Power Antenna Malfunction (GROUP 39, NO. 212/932)
- Water Leak At Sunroof - Repair (GROUP 83, NO. 203)
- Seat Heater Installation - Procedure (GROUP 85, NO. 116)
- Sunroof Weatherstrip, Replacement (GROUP 83, NO. 202)
- More New Car Features (GROUP 00, NO. 203)
- Wiper/Washer Systems
- Wiring System (Data Link Connectors, Pwr Dist., Grnd Dist.)
- DTC 1-4-4 In Ignition Control Module - Manual Update (GROUP 28, NO. 212X)
- New Cable Terminal As A Replacement Part (GROUP 37, NO. 207)
- Measurement Of Voltage Drop Across Ground Connection (GROUP 37, NO. 204)
- New Sealed Crimping Sleeve For Wiring Connections (GROUP 37, NO. 701)
- More New Car Features (GROUP 00, NO. 203)
- Service Manual Correction - SRS Wiring Text (GROUP 88, NO. 105)