LEMON Manuals: Even more car manuals for everyone
Home >> Pontiac >> 2005 >> Sunfire Standard >> Repair and Diagnosis >> Transmission >> Manual Trans >> Manual Transmission - GETRAG 5 Speed >> Repair Instructions >> Shift Control Cable Replacement >> Removal Procedure

Removal Procedure

    CAUTION: Refer to Battery Disconnect Caution in Cautions and Notices.
  1. Disconnect the negative battery cable.
  2. Remove the console. Refer to Console Replacement - Front Floor in Instrument Panel, Gages, and Console.
    3. Fig 1: View Of Cable Retainer
    GM623628Courtesy of GENERAL MOTORS CORP.
  3. Lift up on the cable retainers.
  4. Disconnect the cable ends from the shifter.
    5. Fig 2: Identifying Forward Cable Locking Tabs
    GM623621Courtesy of GENERAL MOTORS CORP.
  5. Depress the locking tabs and remove the forward cable from the anchor.
  6. Remove the Air Inlet Duct.
    7. Fig 3: View Of Shift Actuator
    GM621601Courtesy of GENERAL MOTORS CORP.
  7. On the transmission end, disconnect the cable from the shift actuator.
    8. Fig 4: Locating Shift Control Cable Ends On Underhood Cable Bracket
    GM494730Courtesy of GENERAL MOTORS CORP.
  8. Remove both cables from the underhood cable bracket.
  9. Position aside the passenger front carpet. Refer to Carpet Replacement - Front in Interior Trim.
    10. Fig 5: Identifying Right Rear Floor Duct Elbow
    GM494662Courtesy of GENERAL MOTORS CORP.
  10. Remove the right rear floor duct elbow.
    11. Fig 6: View Of Passenger Floor Pan Opening
    GM494426Courtesy of GENERAL MOTORS CORP.
  11. Separate the grommet from the floor plan.
  12. Pull the cables through the passenger floor opening.
scientia non olet · About LEMON Manuals