Technical Service Bulletins: Other Variant
WARNING: This page is about the Zephyr Base, 2.3 A, Automatic, which is a different variant/trim than selected.
- A/C Compressor
- Filtering Refrigerant After Compressor Replacement (98-12-5)
- Use Of R-12 Refrigerant Substitutes (96-17-10)
- A/C System Service - List Of Bulletins To Reference (96-15-6)
- R-12 Refrigerant Substitutes - Service Tip (94-14-3)
- Use Of Correct Fluorescent Tracer Dye - Service Tip (93-20-6)
- 2.3/3.8L Eng A/C Compressor Clutch Replacement (87-5-4)
- A/C Clutch Cycling Pressure Switch Diagnosis (87-6-4)
- A/C Garter Springs Missing - Spring/O-Ring Part No.S (85-6-2)
- WARNER A/C Compressor Clutch Assembly R & R (85-4-3)
- A/C Compressor Clutch Assembly I.D. (85-23-3)
- Accessories Control Systems
- Anti-Theft Systems
- Treating Cosmetic Paint Damage From AIRBORN Material (89-13-3)
- Power Door Locks Inoperative - Rod Retainer Clip (88-7-1)
- Aftermarket Theft Device - EEC Warnings (86-3-9)
- Aluminum Wheels W/Coating Service Wear Information (86-9-9)
- Door & Vent Windows - Excessive Efforts To Open (85-4-2)
- Anti-Theft INOP - Contaminated Mating Connector (83-18-6)
- Inoperative Hood Latch Assembly - New Clip (83-7-2)
- Automatic Trans
- Adhesives & Sealants - Availability & Usage (89-12-2)
- New ATF Applications Chart (87-18-14)
- Engine Oil Health Warning: Skin Contact (86-15-7)
- New Synthetic Trans Fluid Information/Application (86-11-17)
- Approved Adhesives & Sealants For Eng/Trans/Steering (89-6T-7)
- C3/C4/C5/A4LD/4HP22/AOD Trans Vent Leak - New Seal (86-19-11)
- C5 Trans Revised Rear Output Shaft/Seal (83-9-5)
- Auxiliary Emission Control Systems
- Hard Start - Revised DURASPARK II Ignition Module (90-1-5)
- Throttle Position Sensor Screw Removal (89-14-7)
- Electronic Modules - Damage From Static Electricity (88-13-3)
- Wiring System Testing Caution - Modify Probe Tips (87-2-5)
- Poor Performance - Vacuum System Diagnosis (86-9-11)
- EGR Solenoid/Vacuum Harness Contamination Caution (85-13-5)
- 2.0/2.3L Rough Idle/Run - Feedback Solenoid Gasket (85-3-6)
- 2.3L Eng Clunk/Hesitation/Surge - Updated Ecu (84-24-7-S)
- 5.0/5.8L Eng Poor Idle/Power/Mpg - THERMACTOR Hoses (84-20-7S)
- 5.0L CANADA Models Rough Idle/Poor Mpg - Modify Carb (84-16-21)
- 2.3L Eng Spark Knock - Retard Ignition Timing (83-1-7)
- 3.3L Eng Cold Hesitation - New CSSH PVS (83-5-11)
- 3.3L Hard Start After Hot Soak - Modify Vent Line (83-13-14)
- Blowers, Superchargers & Turbochargers
- Body Interior
- Charging Systems
- Clutch
- Cooling System (Mechanical)
- Hard Start - Revised DURASPARK II Ignition Module (90-1-5)
- Adhesives & Sealants - Availability & Usage (89-12-2)
- Engine Oil Health Warning: Skin Contact (86-15-7)
- Fuel Stabilizer During Extended Vehicle Storage (86-13-20)
- Diagnostic Tips For Heater Core Leaks (85-5-2)
- CFI/EFI Eng Fuel Injector O-Ring Part Numbers (84-15-12)
- Valve Stem Seal Installation - Nylon Seals Soaking (84-8-11)
- Leaks Oil - Current Seals For Rocker Cover & Oil Pan (83-5-7)
- 2.3L Eng Spark Knock - Retard Ignition Timing (83-1-7)
- 2.0/2.3L Eng Oil Consumption - Valve Stem Seals (83-11-6)
- Approved Adhesives & Sealants For Eng/Trans/Steering (89-6T-7)
- Differentials & Drive Axles
- Engine Control Systems
- Hard Start - Revised DURASPARK II Ignition Module (90-1-5)
- Throttle Position Sensor Screw Removal (89-14-7)
- Electronic Modules - Damage From Static Electricity (88-13-3)
- Wiring System Testing Caution - Modify Probe Tips (87-2-5)
- Aftermarket Theft Device - EEC Warnings (86-3-9)
- Gas Check - Gasoline Testing Kit (86-13-21)
- Poor Performance - Vacuum System Diagnosis (86-9-11)
- EGR Solenoid/Vacuum Harness Contamination Caution (85-13-5)
- 2.0/2.3L Rough Idle/Run - Feedback Solenoid Gasket (85-3-6)
- 2.3L Eng Clunk/Hesitation/Surge - Updated Ecu (84-24-7-S)
- 5.0/5.8L Eng Poor Idle/Power/Mpg - THERMACTOR Hoses (84-20-7S)
- 3.3L Eng C3/C5 Trans Dieseling On Shutdown (83-10-12-S)
- 2.3L Eng Spark Knock - Retard Ignition Timing (83-1-7)
- Entertainment Systems
- Exhaust
- Exterior Body Panels
- Exterior Lights
- Frames, Subframes & Crossmembers
- Fuel System
- Hard Start - Revised DURASPARK II Ignition Module (90-1-5)
- Inaccurate Speedo Readings - Mechanical & Electronic (89-2-7)
- CFI Fuel Injector Contamination - Replace Injector (87-17-5)
- Engine Oil Health Warning: Skin Contact (86-15-7)
- Gas Check - Gasoline Testing Kit (86-13-21)
- Fuel Filter R & R Caution - Use New Clamps/Hoses (85-6-10)
- Carb Eng Poor Cold DRIVEABILITY - Check Air Intake (83-21-4)
- 3.3L Eng C3/C5 Trans Dieseling On Shutdown (83-10-12-S)
- 2.3L Eng Spark Knock - Retard Ignition Timing (83-1-7)
- Fuses & Circuit Breakers
- Gauges & Instrument Panels
- General Servicing
- Hazardous Waste Material
- Headlights
- Heated Glass/Defoggers
- HVAC Control Systems
- Filtering Refrigerant After Compressor Replacement (98-12-5)
- Use Of R-12 Refrigerant Substitutes (96-17-10)
- A/C System Service - List Of Bulletins To Reference (96-15-6)
- A/C "O" Ring Removal From Spring Lock Coupling (95-2-2)
- R-12 Refrigerant Substitutes - Service Tip (94-14-3)
- Use Of Correct Fluorescent Tracer Dye - Service Tip (93-20-6)
- A/C Chemical Smell - Clutch Cycling Pressure Switch (91-11-8)
- Air Conditioning Odor Treatment - Service Procedure (89-25B-1)
- Electronic Modules - Damage From Static Electricity (88-13-3)
- A/C Low Side Pressure Hose Service Adapter Tool (87-7-2)
- Diagnostic Tips For Heater Core Leaks (85-5-2)
- A/C Garter Springs Missing - Spring/O-Ring Part No.S (85-6-2)
- Identification
- Ignition Switch/Steering Lock
- Ignition System
- Hard Start - Revised DURASPARK II Ignition Module (90-1-5)
- Revised DURA Spark Ignition Module (89-10T-3)
- TFI Module/Pip Sensor New EEC-IV Testing (87-21-10)
- New Distributor Drive Gear Removal Tool (87-2-18)
- Fuel Stabilizer During Extended Vehicle Storage (86-13-20)
- Miss/Stall/Ignition Radio Noise - Ignition Coil (86-2-8)
- TFI Ignition System Resistance Test - Tips/Caution (86-2-19)
- TFI Ignition System Weak/No Spark - Diagnostic Tips (86-2-20)
- 4/6/8 CYL No Start/Runs Rough - New Distributor Cap (84-22-3-S)
- Stalls/Stumbling - Spark Plug Cable Routing (84-4-21)
- 2.3L Eng Hard Cold Start - Choke Index Baffle Plate (84-10-12)
- 2.0/2.3/4.9L Hard Start/Rough Idle - Fuel Inlet (84-17-13)
- CFI/EFI Eng Fuel Injector O-Ring Part Numbers (84-15-12)
- 2.3L Eng Spark Knock - Retard Ignition Timing (83-1-7)
- 1.6/3.3L Eng Carburetor Flooding - New Filter (83-7-12)
- Distributor Centrifugal Advance Not Serviceable (83-10-15)
- Interior/Exterior Trim
- Interior/Illumination Lights
- Lubrication System
- Adhesives & Sealants - Availability & Usage (89-12-2)
- Engine Oil Health Warning: Skin Contact (86-15-7)
- Fuel Stabilizer During Extended Vehicle Storage (86-13-20)
- Using Oil-Leak-BLACKLITE (85-5-13)
- Fuel Odor - Liquid/Vapor Leak Diagnosis (85-1-16)
- CFI/EFI Eng Fuel Injector O-Ring Part Numbers (84-15-12)
- Valve Stem Seal Installation - Nylon Seals Soaking (84-8-11)
- Leaks Oil - Current Seals For Rocker Cover & Oil Pan (83-5-7)
- 1.6/3.3L Eng Carburetor Flooding - New Filter (83-7-12)
- 2.0/2.3L Eng Oil Consumption - Valve Stem Seals (83-11-6)
- Approved Adhesives & Sealants For Eng/Trans/Steering (89-6T-7)
- Rear Crankshaft Seal Oil Leak Diagnostic Info (83-14-8)
- Manual Steering
- Adhesives & Sealants - Availability & Usage (89-12-2)
- Engine Oil Health Warning: Skin Contact (86-15-7)
- Power Steering CII Pump Leakage At Dipstick Cap (86-9-7)
- Power Steering Dipstick Leaking - Center Vent Stick (85-1-11-S)
- Power Steering Service - New Short Rack Kit (83-22-11)
- Power Steering Fluid Dark Colored (83-17-5)
- Power Steering Pump Rotor/C-Clip Changes (83-10-6)
- Power Steer New Rack & Pinion Gear Housing/Valve Bore (82-25-12)
- Manual Trans
- Mechanical
- Hard Start - Revised DURASPARK II Ignition Module (90-1-5)
- Adhesives & Sealants - Availability & Usage (89-12-2)
- Fuel Stabilizer During Extended Vehicle Storage (86-13-20)
- Using Oil-Leak-BLACKLITE (85-5-13)
- Fuel Odor - Liquid/Vapor Leak Diagnosis (85-1-16)
- 2.3L Eng Hard Cold Start - Choke Index Baffle Plate (84-10-12)
- 2.0/2.3/4.9L Hard Start/Rough Idle - Fuel Inlet (84-17-13)
- CFI/EFI Eng Fuel Injector O-Ring Part Numbers (84-15-12)
- Valve Stem Seal Installation - Nylon Seals Soaking (84-8-11)
- Carb Eng Poor Cold DRIVEABILITY - Check Air Intake (83-21-4)
- Leaks Oil - Current Seals For Rocker Cover & Oil Pan (83-5-7)
- Oil Dipstick Level Markings (83-13-7)
- 2.3L Eng Spark Knock - Retard Ignition Timing (83-1-7)
- 1.6/3.3L Eng Carburetor Flooding - New Filter (83-7-12)
- 2.0/2.3L Eng Oil Consumption - Valve Stem Seals (83-11-6)
- Approved Adhesives & Sealants For Eng/Trans/Steering (89-6T-7)
- Rear Crankshaft Seal Oil Leak Diagnostic Info (83-14-8)
- Mechanical - Hydraulic
- Wheels - Proper Lug Torque Procedures - Service Tip (98-5A-4)
- Engine Oil Health Warning: Skin Contact (86-15-7)
- Brake Rotors Updated Diagnosis/Service (85-9-8)
- Brake Fluid Discoloration Diagnosis (84-12-8)
- Asbestos Brake & Clutch Warnings (83-22-1)
- Long Brake PADAL Travel/Spongy Brakes - New Caliper (83-20-9)
- Riveted Rear Brake Shoe Squeal - New Bonded Shoe (86-19-5)
- Mirrors
- Paint & Coatings
- Passive Restraints
- Seats
- Safety Belt Tongue Cover Parts Availability (88-25-2)
- Safety Belt - Replacement Procedure After Accident (88-15-3)
- Power Door Locks Inoperative - Rod Retainer Clip (88-7-1)
- Door & Vent Windows - Excessive Efforts To Open (85-4-2)
- Seat/Shoulder Belt General Service Information (85-2-4)
- Battery Drain - Electrical Component Diagnosis (84-15-9)
- Sleeper
- Starter
- Hard Start - Revised DURASPARK II Ignition Module (90-1-5)
- Fuel Stabilizer During Extended Vehicle Storage (86-13-20)
- 2.3L Eng Hard Cold Start - Choke Index Baffle Plate (84-10-12)
- 2.0/2.3/4.9L Hard Start/Rough Idle - Fuel Inlet (84-17-13)
- CFI/EFI Eng Fuel Injector O-Ring Part Numbers (84-15-12)
- Battery Test Procedure Using Rotunda Battery Tester (83-8-2)
- 1.6/3.3L Eng Carburetor Flooding - New Filter (83-7-12)
- Steering Control Systems
- Steering Gear
- Adhesives & Sealants - Availability & Usage (89-12-2)
- Power Steering CII Pump Leakage At Dipstick Cap (86-9-7)
- Power Steering Dipstick Leaking - Center Vent Stick (85-1-11-S)
- Power Steering Service - New Short Rack Kit (83-22-11)
- Power Steer New Rack & Pinion Gear Housing/Valve Bore (82-25-12)
- Approved Adhesives & Sealants For Eng/Trans/Steering (89-6T-7)
- Steering Linkage
- Sun Roof/T-Top/Convertible Top
- Suspension Control Systems
- System
- Hard Start - Revised DURASPARK II Ignition Module (90-1-5)
- Revised DURA Spark Ignition Module (89-10T-3)
- Throttle Position Sensor Screw Removal (89-14-7)
- Adhesives & Sealants - Availability & Usage (89-12-2)
- Electronic Modules - Damage From Static Electricity (88-13-3)
- TFI Module/Pip Sensor New EEC-IV Testing (87-21-10)
- CFI Fuel Injector Contamination - Replace Injector (87-17-5)
- New Distributor Drive Gear Removal Tool (87-2-18)
- Wiring System Testing Caution - Modify Probe Tips (87-2-5)
- Aftermarket Theft Device - EEC Warnings (86-3-9)
- Fuel Stabilizer During Extended Vehicle Storage (86-13-20)
- Gas Check - Gasoline Testing Kit (86-13-21)
- Poor Performance - Vacuum System Diagnosis (86-9-11)
- Miss/Stall/Ignition Radio Noise - Ignition Coil (86-2-8)
- TFI Ignition System Resistance Test - Tips/Caution (86-2-19)
- TFI Ignition System Weak/No Spark - Diagnostic Tips (86-2-20)
- EGR Solenoid/Vacuum Harness Contamination Caution (85-13-5)
- 2.0/2.3L Rough Idle/Run - Feedback Solenoid Gasket (85-3-6)
- 4/6/8 CYL No Start/Runs Rough - New Distributor Cap (84-22-3-S)
- Stalls/Stumbling - Spark Plug Cable Routing (84-4-21)
- 2.3L Eng Clunk/Hesitation/Surge - Updated Ecu (84-24-7-S)
- 5.0/5.8L Eng Poor Idle/Power/Mpg - THERMACTOR Hoses (84-20-7S)
- 2.3L Eng Hard Cold Start - Choke Index Baffle Plate (84-10-12)
- 2.0/2.3/4.9L Hard Start/Rough Idle - Fuel Inlet (84-17-13)
- 5.0L CANADA Models Rough Idle/Poor Mpg - Modify Carb (84-16-21)
- CFI/EFI Eng Fuel Injector O-Ring Part Numbers (84-15-12)
- Valve Stem Seal Installation - Nylon Seals Soaking (84-8-11)
- 3.3L Eng C3/C5 Trans Dieseling On Shutdown (83-10-12-S)
- Leaks Oil - Current Seals For Rocker Cover & Oil Pan (83-5-7)
- 2.3L Eng Spark Knock - Retard Ignition Timing (83-1-7)
- 1.6/3.3L Eng Carburetor Flooding - New Filter (83-7-12)
- 2.0/2.3L Eng Oil Consumption - Valve Stem Seals (83-11-6)
- 3.3L Eng Cold Hesitation - New CSSH PVS (83-5-11)
- 3.3L Hard Start After Hot Soak - Modify Vent Line (83-13-14)
- Approved Adhesives & Sealants For Eng/Trans/Steering (89-6T-7)
- Distributor Centrifugal Advance Not Serviceable (83-10-15)
- Rear Crankshaft Seal Oil Leak Diagnostic Info (83-14-8)
- Transfer Case
- Vacuum Pumps/Lines/Tanks/Water Trap
- Wheels & Tire System
- Window Motors & Regulators
- Wiper/Washer Systems
- Wiring System (Data Link Connectors, Pwr Dist., Grnd Dist.)