Technical Service Bulletins

A/C Compressor
- New Sae J2788 Refrigerant Recovery Standard (IB07-12-S004)
- Contaminated R134A Refrigerant Found On Market For Automotive Air-Conditioning Systems (IB06-12-S001)
- Replacement Of The Receiver Drier During Air Conditioning Repair And Service (IB00-12-S002)
Accessories & Equipment
- Diagnosing Vibration Concern (IB05-14-S001)
Accessories Control Systems
- Specified Major Emission-Control Components Defect Warranty Coverage Enhancement (WB07-L004)
- Tailgate Glass Breakage After Installation Of Aftermarket Film Tint Material (IB00-S009)
Aerodynamic Devices
- Wind Noise And Deflection (IB00-11-S002)
Air Bag, SRS
- ISUZU Dealer Advisory Availability Of Airbag On-Off Switch Kits (Supersedes Sb98-04-L003) (SB98-04-L009)
- New Dual Air Bag Safety Materials (SB97-04-L001)
- SRS Sensing & Diagnostic Module - Manual Update (SB96-04-L007)
Anti-Lock Brakes
- DTC 32, 33 - Abs Light Comes On While Driving (SB97-09-L002)
- Abs DTC 31 - 2WD Controller In 4WD - Manual Update (SB96-09-L007)
- Rear Axle Service Manual Revision -Includes Abs Ring (SB96-07-L002)
- Abs Warning Light Comes On While Vehicle Is Driven; Abs DTC 32 And/Or 33 Sets (SB97-09-L002)
Anti-Theft Systems
- Misfire DTCs P0300, P1380, P1381 and Catalytic Converter Damage Due to Installation of Alarm Systems (02-06-05-004B)
- Misfire DTC'S And Catalytic Converter Damage Due To Installation Of Alarm Systems (IB04-03-S001)
- CURTIS Key Code Cutter And Application Listing (SB03-14-S001)
- Accessory Center Console Stay Breakage (SB97-13-L002)
- L. Rear Door Does Not Power Unlock/Unlocks Manually (SB97-11-L005)
Automatic Trans
- Diagnosing Vibration Concern (IB05-14-S001)
- 4L30E/4L60E Transmission Fluid (IB03-05-S001)
- DTC P1870 And The 4L30E Automatic Transmission (SB03-05-S001)
- LOCTITE/PERMATEX Cross-Reference Chart (SB99-14-S001)
- Fluid Seepage And Fluid Leakage (IB02-14-S001)
- Use Of Surface Conditioning Discs (IB00-14-S001)
Auxiliary Emission Control Systems
- Specified Major Emission-Control Components Defect Warranty Coverage Enhancement (WB07-L004)
- Sulfur (Rotten Egg) Smell From The Exhaust (IB03-03-S001)
- Reprogramming Of Powertrain Control Modules (Pcm) (IB03-14-S002)
- DRIVEABILITY And Emissions (SB98-03-L005)
- 3.2L DRIVEABILITY & Emissions Workshop Corrections (SB98-03-L001)
- 3.2L V6 Eng Pcm DTC Diagnosis;DTCS P0461,P0462,P0463 (SB97-03-L003)
- Programming Of Over-The-Counter-Purchased PCMS (SB97-03-L004)
- 3.2L Eng. Intermittent Low Power/Hesitation - Codes (SB97-01-L002)
- EHANCED Evaporative Emission Control Special Tools (SB97-03-L001)
Axle Shafts
- 2WD Front Hub Grease Leakage - Replace Gasket (SB97-06-L001)
Brakes Control Systems
- DTC 32, 33 - Abs Light Comes On While Driving (SB97-09-L002)
- Abs DTC 31 - 2WD Controller In 4WD - Manual Update (SB96-09-L007)
- Rear Axle Service Manual Revision -Includes Abs Ring (SB96-07-L002)
- Abs Warning Light Comes On While Vehicle Is Driven; Abs DTC 32 And/Or 33 Sets (SB97-09-L002)
Charging Systems
- Low Voltage Display On IP Gauge, Lights Dim At Stop Lights, Battery Discharged, No Start, Slow Cranking, Dim Lights At Idle, Low Generator Output (IB07-04-S003)
Clutch
- Borg-WARNER Manual Transmission Noise From Bell Housing Area (SB98-05-L005)
Cooling System (Mechanical)
- Fluid Seepage And Fluid Leakage (IB02-14-S001)
- 3.2L V6 Engine Water Pump Installation - Manual Rev. (SB97-01-L009)
Cruise Control Systems
- Inspection Of All Related Wiring Harness Connections When Diagnosing Miscellaneous DTC'S, Intermittent DRIVEABILITY Concerns, Hard Start, No Start, Incorrect Gauges, Inoperative Air Conditioning Systems, Service Engine Soon Lamps Illuminated, 4WD Lamp Illuminated, Instrument Panel Gauges Inoperative, Cruise Inoperative (IB05-04-S005)
Differentials & Drive Axles
- Driveline Clunk (IB05-05-S005)
- Fluid Seepage And Fluid Leakage (IB02-14-S001)
- Rear Axle Service Manual Revision -Includes Abs Ring (SB96-07-L002)
Engine Control Systems
- Specified Major Emission-Control Components Defect Warranty Coverage Enhancement (WB07-L004)
- Misfire DTCs P0300, P1380, P1381 and Catalytic Converter Damage Due to Installation of Alarm Systems (02-06-05-004B)
- Reprogramming Of Powertrain Control Modules (Pcm) (IB03-14-S002)
- Pcm Reprogramming (IB00-S002)
- DRIVEABILITY And Emissions (SB98-03-L005)
- 3.2L DRIVEABILITY & Emissions Workshop Corrections (SB98-03-L001)
- 3.2L V6 Eng Pcm DTC Diagnosis;DTCS P0461,P0462,P0463 (SB97-03-L003)
- Programming Of Over-The-Counter-Purchased PCMS (SB97-03-L004)
- 3.2L Eng. Intermittent Low Power/Hesitation - Codes (SB97-01-L002)
- DRIVEABILITY & Emissions Workshop Manual Corrections - DTC P0102 (SB98-03-L005)
Entertainment Systems
- Compact Disc Player Precautions (IB02-13-S001)
- Compact Disc (Cd) Player/Changer And Compatible Compact Discs (SB99-13-S004)
- Cd Player/Changer & Compatible Compact Discs (SB99-13-S004)
Exhaust
- Misfire DTC'S And Catalytic Converter Damage Due To Installation Of Alarm Systems (IB04-03-S001)
- Sulfur (Rotten Egg) Smell From The Exhaust (IB03-03-S001)
- Adjustment Of J-45735 Exhaust BACKPRESSURE Gauge (IB03-14-S001)
- 2.3L/2.6L Engine Exhaust Manifold Stud Nut Removal (SB97-01-L004)
Exterior Body Panels
- Urethane Adhesives For Stationary Glass And Other Applications (02-08-48-001A)
- 3.2L V6 Eng Pcm DTC Diagnosis;DTCS P0461,P0462,P0463 (SB97-03-L003)
- 3.2L Eng. Fuel Gauge Sending Unit Inspection - Rev. (SB97-02-L006)
Frames, Subframes & Crossmembers
- Diagnosing Vibration Concern (IB05-14-S001)
Fuel System
- Top Tier Detergent Gasoline (IB06-02-S001)
- Sulfur (Rotten Egg) Smell From The Exhaust (IB03-03-S001)
- Reprogramming Of Powertrain Control Modules (Pcm) (IB03-14-S002)
- DRIVEABILITY And Emissions (SB98-03-L005)
- DRIVEABILITY & Emissions Workshop Manual Corrections - DTC P0102 (SB98-03-L005)
Fuses & Circuit Breakers
- '96 Rodeo Elect. Troubleshooting Man. Carryover '97 (SB97-04-L003)
- Instrument Harness Damage At Steering Reinforcement (SB97-10-L001)
- 4L30-E Ground Wire Revision - Service Manual Update (SB96-05-L009)
Gauges & Instrument Panels
- Low Voltage Display On IP Gauge, Lights Dim At Stop Lights, Battery Discharged, No Start, Slow Cranking, Dim Lights At Idle, Low Generator Output (IB07-04-S003)
- Inspection Of All Related Wiring Harness Connections When Diagnosing Miscellaneous DTC'S, Intermittent DRIVEABILITY Concerns, Hard Start, No Start, Incorrect Gauges, Inoperative Air Conditioning Systems, Service Engine Soon Lamps Illuminated, 4WD Lamp Illuminated, Instrument Panel Gauges Inoperative, Cruise Inoperative (IB05-04-S005)
- 3.2L V6 Eng Pcm DTC Diagnosis;DTCS P0461,P0462,P0463 (SB97-03-L003)
- 3.2L Eng. Fuel Gauge Sending Unit Inspection - Rev. (SB97-02-L006)
- 3.2L V6 Engine I/P Fuel Gauge Does Not Indicate Full (SB97-02-L004)
- Accessory Center Console Stay Breakage (SB97-13-L002)
Headlights
- Low Voltage Display On IP Gauge, Lights Dim At Stop Lights, Battery Discharged, No Start, Slow Cranking, Dim Lights At Idle, Low Generator Output (IB07-04-S003)
HVAC Control Systems
- New Sae J2788 Refrigerant Recovery Standard (IB07-12-S004)
- Inspection Of All Related Wiring Harness Connections When Diagnosing Miscellaneous DTC'S, Intermittent DRIVEABILITY Concerns, Hard Start, No Start, Incorrect Gauges, Inoperative Air Conditioning Systems, Service Engine Soon Lamps Illuminated, 4WD Lamp Illuminated, Instrument Panel Gauges Inoperative, Cruise Inoperative (IB05-04-S005)
- A/C Refrigerant System Sealer And A/C System Leak Detecting Guidelines (IB04-12-S001)
- Replacement Of The Receiver Drier During Air Conditioning Repair And Service (IB00-12-S002)
- Heater Core And Casing Leakage (Supersedes Sb00-12-S001) (SB00-12-S003)
- HVAC System Deodorizing Treatment (SB99-12-S002)
- 1991-97 Rodeo (UC) HVAC Blower Motor Water Intrusion (SB99-12-S001)
- HVAC System Deodorizing Treatment (SB98-12-L001)
- Heater Core & Casing Leakage (SB00-12-S003)
- HVAC Blower Motor Water Intrusion (SB99-12-S001)
- Receiver Drier Replacement During Air Conditioning Repair & Service (IB00-12-S002)
Ignition Switch/Steering Lock
- CURTIS Key Code Cutter And Application Listing (SB03-14-S001)
- Ignition Key Difficult To Remove From Ignition (SB97-10-L002)
Ignition System
- Misfire DTCs P0300, P1380, P1381 and Catalytic Converter Damage Due to Installation of Alarm Systems (02-06-05-004B)
Interior/Exterior Trim
- Wind Noise And Deflection (IB00-11-S002)
- Whistling/Fluttering Noise (IB00-11-S001)
- Painting Of PRIMERED Replacement Radiator Grilles (SB97-11-L006)
- Roof Rack Installation Tool (SB96-13-L005)
Lubrication System
- Engine Oil Usage Testing And Reporting (SB07-01-S001)
- Fluid Seepage And Fluid Leakage (IB02-14-S001)
- Precaution In Installing An ISUZU Oil Filter (IB00-01-S001)
- Precaution In Installing An ISUZU Brand Oil Filter (IB00-01-S001)
Manual Steering
- Fluid Seepage And Fluid Leakage (IB02-14-S001)
Manual Trans
- Diagnosing Vibration Concern (IB05-14-S001)
- LOCTITE/PERMATEX Cross-Reference Chart (SB99-14-S001)
- 1995-97 Rodeo (UC) Borg-WARNER Manual Transmission Noise From Bell Housing Area (SB98-05-L005)
Mechanical
- Diagnosing Vibration Concern (IB05-14-S001)
- Use Of Surface Conditioning Disks (IB05-01-S002)
- Adjustment Of J-45735 Exhaust BACKPRESSURE Gauge (IB03-14-S001)
- LOCTITE/PERMATEX Cross-Reference Chart (SB99-14-S001)
- Use Of Surface Conditioning Discs (IB00-14-S001)
- Precaution In Installing An ISUZU Oil Filter (IB00-01-S001)
- 3.2L V6 Engine Water Pump Installation - Manual Rev. (SB97-01-L009)
- 3.2L V6 SOHC Eng. SVC. Procedures - Manual Revision (SB97-01-L005)
- 2.3L/2.6L Engine Exhaust Manifold Stud Nut Removal (SB97-01-L004)
- Precaution In Installing An ISUZU Brand Oil Filter (IB00-01-S001)
Mechanical - Hydraulic
- Disc Brake Squeal (IB00-09-S001)
- 1995.5-97 Rodeo (UC) Rear Brakes Squeal/Shudder As Vehicle Is Backing Up (SB98-09-L003)
Mirrors
- L. Rear Door Does Not Power Unlock/Unlocks Manually (SB97-11-L005)
Paint & Coatings
- LOCTITE/PERMATEX Cross-Reference Chart (SB99-14-S001)
- Painting Of PRIMERED Replacement Radiator Grilles (SB97-11-L006)
- 1997 Paint Colors & Codes (SB96-11-L006)
Parking Brake System
- 1995.5-97 Rodeo (UC) Rear Brakes Squeal/Shudder As Vehicle Is Backing Up (SB98-09-L003)
- Rear Brakes Squeal/Shudder When Backing Up (SB98-09-L003)
Passive Restraints
- Seat Belt Extenders (SUV16-00)
- Availability Of Child Seat Tether Anchor Kit (SB99-14-S007)
- Availability Of Supplemental Information Booklet For Installing Child Safety Seats (SB99-14-S003)
- Child Seat Tether Anchor Kit (SB99-14-S007)
Procedures
- Warranty Parts Return Program Relocation (SB99-14-S014)
Restraints Control Systems
- ISUZU Dealer Advisory Availability Of Airbag On-Off Switch Kits (Supersedes Sb98-04-L003) (SB98-04-L009)
Seats
- Seat Belt Extenders (SUV16-00)
- L. Rear Door Does Not Power Unlock/Unlocks Manually (SB97-11-L005)
- Child Seat Tether Anchor Kit (SB99-14-S007)
Starter
- Battery Charging Tips (Includes Information References for HP2 Hybrid Truck [PHT] 42-volt System) (02-06-03-009C)
- Low Voltage Display On IP Gauge, Lights Dim At Stop Lights, Battery Discharged, No Start, Slow Cranking, Dim Lights At Idle, Low Generator Output (IB07-04-S003)
- CALIFORNIA Consent Order On Settlement Of Lawsuit On Batteries (Proposition 65) (IB00-14-S004)
- CALIFORNIA Consent Order-Lawsuit Settlement On Batteries (Proposition 65) (IB00-14-S004)
Steering Column
- Front End Alignment Inspection - SVC. Man. Revision (SB97-06-L002)
Steering Gear
- Front End Alignment Inspection - SVC. Man. Revision (SB97-06-L002)
Steering Linkage
- Front End Alignment Inspection - SVC. Man. Revision (SB97-06-L002)
- 2WD Front Hub Grease Leakage - Replace Gasket (SB97-06-L001)
Sun Roof/T-Top/Convertible Top
- Accessory Center Console Stay Breakage (SB97-13-L002)
- Roof Rack Installation Tool (SB96-13-L005)
System
- Misfire DTCs P0300, P1380, P1381 and Catalytic Converter Damage Due to Installation of Alarm Systems (02-06-05-004B)
- Inspection Of All Related Wiring Harness Connections When Diagnosing Miscellaneous DTC'S, Intermittent DRIVEABILITY Concerns, Hard Start, No Start, Incorrect Gauges, Inoperative Air Conditioning Systems, Service Engine Soon Lamps Illuminated, 4WD Lamp Illuminated, Instrument Panel Gauges Inoperative, Cruise Inoperative (IB05-04-S005)
- Sulfur (Rotten Egg) Smell From The Exhaust (IB03-03-S001)
- Reprogramming Of Powertrain Control Modules (Pcm) (IB03-14-S002)
- LOCTITE/PERMATEX Cross-Reference Chart (SB99-14-S001)
- ISUZU POWERLINK Diagnostics Interface Module Connection (SB01-09-S001)
- DRIVEABILITY And Emissions (SB98-03-L005)
- 3.2L DRIVEABILITY & Emissions Workshop Corrections (SB98-03-L001)
- 3.2L V6 Eng Pcm DTC Diagnosis;DTCS P0461,P0462,P0463 (SB97-03-L003)
- Programming Of Over-The-Counter-Purchased PCMS (SB97-03-L004)
- 3.2L Eng. Intermittent Low Power/Hesitation - Codes (SB97-01-L002)
- EHANCED Evaporative Emission Control Special Tools (SB97-03-L001)
- DRIVEABILITY & Emissions Workshop Manual Corrections - DTC P0102 (SB98-03-L005)
- Pcm Reprogramming (IB00-S002)
- Use Of Surface Conditioning Discs (IB00-14-S001)
Transfer Case
- Inspection Of All Related Wiring Harness Connections When Diagnosing Miscellaneous DTC'S, Intermittent DRIVEABILITY Concerns, Hard Start, No Start, Incorrect Gauges, Inoperative Air Conditioning Systems, Service Engine Soon Lamps Illuminated, 4WD Lamp Illuminated, Instrument Panel Gauges Inoperative, Cruise Inoperative (IB05-04-S005)
- Fluid Seepage And Fluid Leakage (IB02-14-S001)
Transmission Control Systems
- Specified Major Emission-Control Components Defect Warranty Coverage Enhancement (WB07-L004)
- Pcm Reprogramming (IB00-S002)
- Abs DTC 31 - 2WD Controller In 4WD - Manual Update (SB96-09-L007)
Wheel Hubs
- 2WD Front Hub Grease Leakage - Replace Gasket (SB97-06-L001)
Wheels & Tire System
- Information On Proper Tire Pressure (IB06-08-S003)
- Use Of The HAWEKA Flange Plate Adapter For Tire Balancers (IB01-14-S005)
- 3/4 Inch (19MM) Wheel Lug Torque Stick (SB99-14-S008)
- 2WD Front Hub Grease Leakage - Replace Gasket (SB97-06-L001)
- 3/4" (19 Mm) Wheel Lug Torque Stick (SB99-14-S008)
Window Motors & Regulators
- Urethane Adhesives For Stationary Glass And Other Applications (02-08-48-001A)
- Automotive Safety Glass Identification And Maintenance (IB01-11-S001)
- Tailgate Glass Breakage After Installation Of Aftermarket Film Tint Material (IB00-S009)
- Accessory Center Console Stay Breakage (SB97-13-L002)
- L. Rear Door Does Not Power Unlock/Unlocks Manually (SB97-11-L005)
Wiring System (Data Link Connectors, Pwr Dist., Grnd Dist.)
- '96 Rodeo Elect. Troubleshooting Man. Carryover '97 (SB97-04-L003)
- Instrument Harness Damage At Steering Reinforcement (SB97-10-L001)
- 4L30-E Ground Wire Revision - Service Manual Update (SB96-05-L009)
- Abs Warning Light Comes On While Vehicle Is Driven; Abs DTC 32 And/Or 33 Sets (SB97-09-L002)