Technical Service Bulletins
- A/C Compressor
- Filtering Refrigerant After Compressor Replacement (98-12-5)
- Identification Of Non-Ford Approved Refrigerants (99-19-6)
- Use Of R-12 Refrigerant Substitutes (96-17-10)
- A/C System Service - List Of Bulletins To Reference (96-15-6)
- Ford Approved Flushing Procedures For A/C System (95-8-1)
- R-12 Refrigerant Substitutes - Service Tip (94-14-3)
- Engine Hesitation/Stall/Low Eng Temp: Diagnosis (93-24-8)
- Use Of Correct Fluorescent Tracer Dye - Service Tip (93-20-6)
- A/C SLC Refrigerant Fittings Cleaning/New O-Ring Kit (93-6-5)
- New Refrigerant Fitting "O" Rings (91-22-5)
- Air Conditioning - Refrigerant R-12 - Service Tips (91-9-7)
- A/C "O" Ring Usage Table (90-14-8)
- Poor A/C - Clutch Pressure Cycling Switch Diagnosis (89-14-10)
- A/C Clutch Cycling Pressure Switch Diagnosis (87-6-4)
- A/C Garter Springs Missing - Spring/O-Ring Part No.S (85-6-2)
- A/C Clutch Pressure Cycling Switch Diagnostic (89-7T-19)
- A/C Compressor Clutch Assembly I.D. (85-23-3)
- Accessories Control Systems
- Aerodynamic Devices
- Anti-Theft Systems
- No Crank - Low State Of Battery Charge (91-10-8)
- Latches - Door - Replacement Required (91-8-4)
- Treating Cosmetic Paint Damage From AIRBORN Material (89-13-3)
- Manual Vent Windows - Glass Sticks To Weatherstrip (88-14-1)
- Power Door Locks Inoperative - Rod Retainer Clip (88-7-1)
- Door Handle/Switches Air Leak - Foam Gaskets (87-17-9)
- Aftermarket Theft Device - EEC Warnings (86-3-9)
- Aluminum Wheels W/Coating Service Wear Information (86-9-9)
- Door & Vent Windows - Excessive Efforts To Open (85-4-2)
- Door Locks Inoperative - Aftermarket Rustproofing (85-12-2)
- Front Door Power Latch Inoperative - New Latch (85-12-3)
- Liftgate Handle/Latch Inoperative - Replace Assembly (85-11-15)
- Wind Noise Diagnostic/Repair Procedures (85-8-17)
- Window Regulator Inoperative Or Handle Loose (85-3-1)
- Automatic Trans
- E4OD/4R100 - Fluid In-Line Filter Kit (00-3-8)
- Transmission Flush/Fill Tool Available From Rotunda (99-15-2)
- Transmission Fluid Usage Chart (98-8-8)
- 4R44E/5R55E Trans - New Service Center Support (98-1-12)
- Torque Converter Slip/DTC 628 Or P0741 In Memory (97-22-4)
- Torque Converter Replacement - Cooling SYS. Cleaning (96-26-12)
- Torque Converter Leak Test Procedure - New Tool (96-24-9)
- New Rotunda Fluid Changer - Service Tip (95-16-10)
- Adhesives & Sealants - Availability & Usage (89-12-2)
- Driveline Clank/Ratchet In Reverse - New Driveshaft (88-2-15)
- A4LD Transmission New Front Oil Pump Bolts (87-21-6)
- A/T Cooler Line Connections Leak - Modify Connectors (87-18-13)
- New ATF Applications Chart (87-18-14)
- A4LD/C3 Trans Shifter Assembly Part No./Applications (87-5-34)
- A4LD Trans Leaks/Burnt Fluid/Eng Stall/Erratic Shift (87-2-15)
- A4LD Transmission Overhaul Tips (87-2-16)
- Engine Oil Health Warning: Skin Contact (86-15-7)
- New Synthetic Trans Fluid Information/Application (86-11-17)
- 2.3/2.8 Eng A4LD Trans Leak - New Switch Connector (85-25-24)
- 2.3/2.8 Eng A4LD Trans Stalls - Shuttle Valve Spring (85-25-23)
- Automatic A4LD Transmission Rear End Play Check (85-15-15)
- A4LD Missing Sun Gear Bearing Race - Installation (85-11-19)
- A4LD Sensitive 4-3 Shifting - Spring Replacement (85-11-18)
- A4LD Vibrates Above 45 Mph - Double CARDAN End Yoke (85-10-29)
- C5/A4LD Trans Fluid Leak - Replace Swollen Vent Tube (85-10-26)
- A4LD Stall/Poor Mileage - Front Pump Support Seal (85-8-22)
- A4LD Trans Clutch Plate/Servo Components Use/Id (85-8-21)
- A4LD Trans Proper Torque Converter Installation Info (85-23-18)
- A4LD/AOD/C6 Trans No Forward Gear - Od One-Way CLTCH (86-12-14)
- Approved Adhesives & Sealants For Eng/Trans/Steering (89-6T-7)
- Auxiliary Emission Control Systems
- EXH Gas Oxygen Sensor Silicone Sealer Contamination (93-23-6)
- Nylon Fuel Line Service (92-12-16)
- Electronic Control Modules - Damage From Arc Welding (91-7-5)
- No Start/Low Battery/Fuel Pump Noise - Pump Relay (90-18-3)
- Hard Start - Revised DURASPARK II Ignition Module (90-1-5)
- Emission Maintenance Warning Module - Information (89-22-8)
- TPS Service Replacement Chart (89-16-4)
- Throttle Position Sensor Screw Removal (89-14-7)
- EEC IV Eng & 2.3L/2.5L HSC CFI Map/Bap Sensor Applications Chart (89-1-12)
- Electronic Modules - Damage From Static Electricity (88-13-3)
- Wiring System Testing Caution - Modify Probe Tips (87-2-5)
- Poor Performance - Vacuum System Diagnosis (86-9-11)
- ECM Spout Line Connector Locations (86-4-17)
- 2.8L Eng Surge & Buck - Contaminated EGR Valve (85-19-12)
- EGR Solenoid/Vacuum Harness Contamination Caution (85-13-5)
- Map Sensor New Part Numbers/Applications (85-12-17)
- EGR Valve Position Sensor Part Id Information (85-5-17)
- 2.0/2.3L Rough Idle/Run - Feedback Solenoid Gasket (85-3-6)
- 2.3L Eng Clunk/Hesitation/Surge - Updated Ecu (84-24-7-S)
- 2.3/2.5L Eng New Map/Bap Sensor Application Table (89-1T-19)
- EEC-IV Test Code 53 Throttle Position Sensor Diag (85-20-11)
- Emission Light Stays On - Replace/Reset Procedure (85-21-11)
- EMW/IMS Warning Module Definition Location (89-11T-20)
- Engine Compartment Intermittent Concern Diag Process (85-17-3)
- Revised EEC Power Relay Pin-Out Location (85-15-5)
- Throttle Position Sensor POZIDRIVE Mount Screw Info (89-7T-9)
- Axle Shafts
- 4WD Automatic HUBLOCK Information - Service Tip (95-5-18)
- 4X4 Front Axle I.D. Tags (92-5-14)
- 4X4 General Info, Operating Characteristics & Tips (92-1-8)
- Driveline Clank/Ratchet In Reverse - New Driveshaft (88-2-15)
- Rear Axle Housing Replacement (87-2-27)
- Double CARDAN "U" Joint Periodic Maintenance Info (85-3-13)
- Automatic Hub Lock New Spindle Nut Locking Key/Cam (85-5-27)
- Blowers, Superchargers & Turbochargers
- Body Interior
- Electrical Diode Identification And Replacements (96-24-6)
- A/C Chemical Smell - Clutch Cycling Pressure Switch (91-11-8)
- Latches - Door - Replacement Required (91-8-4)
- Air Conditioning Odor Treatment - Service Procedure (89-25B-1)
- Poor A/C - Clutch Pressure Cycling Switch Diagnosis (89-14-10)
- Inaccurate Speedo Readings - Mechanical & Electronic (89-2-7)
- Manual Vent Windows - Glass Sticks To Weatherstrip (88-14-1)
- Door & Vent Windows - Excessive Efforts To Open (85-4-2)
- A/C Clutch Pressure Cycling Switch Diagnostic (89-7T-19)
- Brakes Control Systems
- Charging Systems
- Clutch
- Driveline Clank/Ratchet In Reverse - New Driveshaft (88-2-15)
- Transmission Fluid Leak - Smooth Mounting/New Gasket (87-25-12)
- Incomplete Clutch Return/Gear Clash - New Pedal (85-12-28)
- Hydraulic Clutch Diagnosis And Parts List (85-5-26)
- Asbestos Brake & Clutch Warnings (83-22-1)
- Knock Noise From Engine - Slave Cylinder Rattling (86-22-20)
- Cooling Fan
- Cooling System (Mechanical)
- Use Of Recycled Coolant - Service Tip (95-18-2)
- Engine Hesitation/Stall/Low Eng Temp: Diagnosis (93-24-8)
- Nylon Fuel Line Service (92-12-16)
- Cooling System - Use Of Recycled Engine Coolant (90-4-10)
- Hard Start - Revised DURASPARK II Ignition Module (90-1-5)
- Adhesives & Sealants - Availability & Usage (89-12-2)
- Revised Electric Fuel Pump Testing (87-11-15)
- Engine Oil Health Warning: Skin Contact (86-15-7)
- Fuel Stabilizer During Extended Vehicle Storage (86-13-20)
- Diagnostic Tips For Heater Core Leaks (85-5-2)
- Fuel Line Retainer Clips Part No.S (85-6-19)
- Aluminum Core Nylon Tank Radiator Repair Caution (85-4-15)
- 2.0/2.2/2.3/2.8/7.5L Eng Exhaust Leak/Noise (85-23-17)
- Approved Adhesives & Sealants For Eng/Trans/Steering (89-6T-7)
- Service PROC For Nylon Fuel Tubes & Push Connectors (85-19-20)
- Differentials & Drive Axles
- 4WD Automatic HUBLOCK Information - Service Tip (95-5-18)
- 4X4 Front Axle I.D. Tags (92-5-14)
- 4X4 General Info, Operating Characteristics & Tips (92-1-8)
- Adhesives & Sealants - Availability & Usage (89-12-2)
- Driveline Clank/Ratchet In Reverse - New Driveshaft (88-2-15)
- Rear Axle Housing Replacement (87-2-27)
- Engine Oil Health Warning: Skin Contact (86-15-7)
- Double CARDAN "U" Joint Periodic Maintenance Info (85-3-13)
- Front Drive Axle Limited Slip Differential Service (85-13-13)
- Driveshaft & Universal Joints
- 4WD Automatic HUBLOCK Information - Service Tip (95-5-18)
- 4X4 Front Axle I.D. Tags (92-5-14)
- 4X4 General Info, Operating Characteristics & Tips (92-1-8)
- Driveline Clank/Ratchet In Reverse - New Driveshaft (88-2-15)
- Rear Axle Housing Replacement (87-2-27)
- Double CARDAN "U" Joint Periodic Maintenance Info (85-3-13)
- Electronic Steering
- Electronic Suspension
- Engine Control Systems
- Engine Hesitation/Stall/Low Eng Temp: Diagnosis (93-24-8)
- Electronic Control Modules - Damage From Arc Welding (91-7-5)
- No Start/Low Battery/Fuel Pump Noise - Pump Relay (90-18-3)
- Hard Start - Revised DURASPARK II Ignition Module (90-1-5)
- Emission Maintenance Warning Module - Information (89-22-8)
- TPS Service Replacement Chart (89-16-4)
- Throttle Position Sensor Screw Removal (89-14-7)
- EEC IV Eng & 2.3L/2.5L HSC CFI Map/Bap Sensor Applications Chart (89-1-12)
- Electronic Modules - Damage From Static Electricity (88-13-3)
- Fuel Line Spring Lock Coupling R & R (87-3-8)
- Wiring System Testing Caution - Modify Probe Tips (87-2-5)
- Aftermarket Theft Device - EEC Warnings (86-3-9)
- Gas Check - Gasoline Testing Kit (86-13-21)
- Poor Performance - Vacuum System Diagnosis (86-9-11)
- ECM Spout Line Connector Locations (86-4-17)
- EGR Solenoid/Vacuum Harness Contamination Caution (85-13-5)
- Map Sensor New Part Numbers/Applications (85-12-17)
- EGR Valve Position Sensor Part Id Information (85-5-17)
- 2.0/2.3L Rough Idle/Run - Feedback Solenoid Gasket (85-3-6)
- 2.3L Eng Clunk/Hesitation/Surge - Updated Ecu (84-24-7-S)
- Surging/High Idle After Battery Is Disconnected (84-19-13)
- 2.3/2.5L Eng New Map/Bap Sensor Application Table (89-1T-19)
- EEC-IV Test Code 53 Throttle Position Sensor Diag (85-20-11)
- Emission Light Stays On - Replace/Reset Procedure (85-21-11)
- EMW/IMS Warning Module Definition Location (89-11T-20)
- Engine Compartment Intermittent Concern Diag Process (85-17-3)
- Revised EEC Power Relay Pin-Out Location (85-15-5)
- Throttle Position Sensor POZIDRIVE Mount Screw Info (89-7T-9)
- Entertainment Systems
- Exhaust
- Exterior Body Panels
- Lower Body Stone Protection Repair Tips (90-15-3)
- Treating Cosmetic Paint Damage From AIRBORN Material (89-13-3)
- Cracks At Swing-Away Spare Tire: New Assembly (88-20-11)
- Manual Vent Windows - Glass Sticks To Weatherstrip (88-14-1)
- Aluminum Wheels W/Coating Service Wear Information (86-9-9)
- Door & Vent Windows - Excessive Efforts To Open (85-4-2)
- Liftgate Handle/Latch Inoperative - Replace Assembly (85-11-15)
- Exterior Lights
- Frames, Subframes & Crossmembers
- Front Suspension
- Fuel System
- CALIFORNIA Reformulated Gasoline - Service Tip (96-10-7)
- Engine Hesitation/Stall/Low Eng Temp: Diagnosis (93-24-8)
- Nylon Fuel Line Service (92-12-16)
- Hard Start - Revised DURASPARK II Ignition Module (90-1-5)
- Emission Maintenance Warning Module - Information (89-22-8)
- Inaccurate Speedo Readings - Mechanical & Electronic (89-2-7)
- CFI Fuel Injector Contamination - Replace Injector (87-17-5)
- Fuel Line Spring Lock Coupling R & R (87-3-8)
- Engine Oil Health Warning: Skin Contact (86-15-7)
- Gas Check - Gasoline Testing Kit (86-13-21)
- Fuel Filter R & R Caution - Use New Clamps/Hoses (85-6-10)
- Fuses & Circuit Breakers
- Wiring - Wire Harness Terminal Repair Kit (99-6-3)
- Electrical - New Terminal Grease For Service (98-24-6)
- Electrical Diode Identification And Replacements (96-24-6)
- Generator Harness Connector Damage - Loose Contact (96-21-4)
- No Crank - Low State Of Battery Charge (91-10-8)
- Wire Harness Terminal & Connector Service Kit (89-19-5)
- Wiring System Diagnosis Cautions (87-4-8)
- Engine Compartment - Use Waterproof Wire Connectors (87-2-6)
- Wiring Diagram Symbols Explanation (85-11-5)
- Wire Color Code Change (85-4-8)
- Gauges & Instrument Panels
- Fuel Tank Sending Unit Wiring Damaged - New Wiring (89-14-6)
- Inaccurate Speedo Readings - Mechanical & Electronic (89-2-7)
- False Lamp Out Warnings - Trailer Lighting Install. (88-2-6)
- Miss/Stall/Ignition Radio Noise - Ignition Coil (86-2-8)
- Trip Odometer Improper Reset - Knob Seating (85-9-46)
- Damaged Fuel Tank Sending Unit Connector Repair (89-7T-14)
- New In Car Fuel Sender Test Procedure (86-15-5)
- General Servicing
- Hazardous Waste Material
- Headlights
- Heated Glass/Defoggers
- HVAC Control Systems
- Climate Control - Repeat Heater Core Failure (01-15-6)
- Filtering Refrigerant After Compressor Replacement (98-12-5)
- Identification Of Non-Ford Approved Refrigerants (99-19-6)
- Use Of R-12 Refrigerant Substitutes (96-17-10)
- A/C System Service - List Of Bulletins To Reference (96-15-6)
- Ford Approved Flushing Procedures For A/C System (95-8-1)
- A/C "O" Ring Removal From Spring Lock Coupling (95-2-2)
- R-12 Refrigerant Substitutes - Service Tip (94-14-3)
- Engine Hesitation/Stall/Low Eng Temp: Diagnosis (93-24-8)
- Use Of Correct Fluorescent Tracer Dye - Service Tip (93-20-6)
- A/C SLC Refrigerant Fittings Cleaning/New O-Ring Kit (93-6-5)
- New Refrigerant Fitting "O" Rings (91-22-5)
- A/C Chemical Smell - Clutch Cycling Pressure Switch (91-11-8)
- Air Conditioning - Refrigerant R-12 - Service Tips (91-9-7)
- Electronic Control Modules - Damage From Arc Welding (91-7-5)
- A/C "O" Ring Usage Table (90-14-8)
- Air Conditioning Odor Treatment - Service Procedure (89-25B-1)
- Poor A/C - Clutch Pressure Cycling Switch Diagnosis (89-14-10)
- Electronic Modules - Damage From Static Electricity (88-13-3)
- A/C New Push Button/Blower Switch (85-10-5)
- Diagnostic Tips For Heater Core Leaks (85-5-2)
- A/C Garter Springs Missing - Spring/O-Ring Part No.S (85-6-2)
- A/C Clutch Pressure Cycling Switch Diagnostic (89-7T-19)
- Identification
- Ignition Switch/Steering Lock
- Ignition System
- Engine Hesitation/Stall/Low Eng Temp: Diagnosis (93-24-8)
- Nylon Fuel Line Service (92-12-16)
- New Idle Air By-Pass Kit & ECA Relearn Procedure (91-7-4)
- Poor Cold Start/Idle/Run - Fuel Recommendations (91-8-13)
- Hard Start - Revised DURASPARK II Ignition Module (90-1-5)
- Distributor Gear Matched To Distributor At Assembly (89-6-11)
- TFI Module/Pip Sensor New EEC-IV Testing (87-21-10)
- 2.0/2.3/2.5/3.0/3.8/5.0/5.8L Eng Short IGN Coil (87-20-18)
- Revised Electric Fuel Pump Testing (87-11-15)
- TFI Stall/No Start - TFI Module Diagnosis/Sealing (87-6-10)
- New Distributor Drive Gear Removal Tool (87-2-18)
- Fuel Stabilizer During Extended Vehicle Storage (86-13-20)
- TFI Eng No Start/Stall At Idle - New Ignition Module (86-11-25)
- ECM Spout Line Connector Locations (86-4-17)
- Miss/Stall/Ignition Radio Noise - Ignition Coil (86-2-8)
- TFI Ignition System Resistance Test - Tips/Caution (86-2-19)
- TFI Ignition System Weak/No Spark - Diagnostic Tips (86-2-20)
- DRIVEABILITY Concerns - Moist EEC-IV Connectors (85-25-9)
- No Start/Rough Idle/Knock - Hall Effect Diagnosis (85-7-11)
- Fuel Line Retainer Clips Part No.S (85-6-19)
- 2.8L Eng Distributor Octane Rod Replacement (85-2-18-S)
- Distributor Stator Assembly R & R (85-4-21)
- 2.3L EFI W/Cast Aluminum Oil Pan - New Oil Capacity (84-24-10)
- Coil Durability & Radio Frequency Interference (84-22-8)
- 2.8/3.8L Carb Eng Stumble/Stall - Heated Carb Spacer (86-25-13)
- Engine Compartment Intermittent Concern Diag Process (85-17-3)
- Low Fuel Pump Voltage Fuel Starvation - Loose Wires (86-11-23)
- No Start EEC IV - E-Core Ignition Coil Damage Test (85-16-13)
- Service PROC For Nylon Fuel Tubes & Push Connectors (85-19-20)
- Infotainment
- Interior/Exterior Trim
- Frame - Rivet Replacement With Bolts - Service Tips (97-4-7)
- Treating Cosmetic Paint Damage From AIRBORN Material (89-13-3)
- Manual Vent Windows - Glass Sticks To Weatherstrip (88-14-1)
- Adhesive BODYSIDE Mouldings & Nameplates Replacement (88-10-4)
- Door Glass Run/Extension Wind Noise - Foam Tape (87-10-16)
- Aluminum Wheels W/Coating Service Wear Information (86-9-9)
- Door & Vent Windows - Excessive Efforts To Open (85-4-2)
- Wind Noise Diagnostic/Repair Procedures (85-8-17)
- Window Regulator Inoperative Or Handle Loose (85-3-1)
- Interior/Illumination Lights
- Locking Hubs
- Lubrication System
- Nylon Fuel Line Service (92-12-16)
- Adhesives & Sealants - Availability & Usage (89-12-2)
- Revised Electric Fuel Pump Testing (87-11-15)
- 2.9/5.0/6.9L Water In Air Intake - New Air Cleaner (87-2-25)
- Engine Oil Health Warning: Skin Contact (86-15-7)
- Fuel Stabilizer During Extended Vehicle Storage (86-13-20)
- Fuel Line Retainer Clips Part No.S (85-6-19)
- Using Oil-Leak-BLACKLITE (85-5-13)
- Fuel Odor - Liquid/Vapor Leak Diagnosis (85-1-16)
- 2.3L EFI W/Cast Aluminum Oil Pan - New Oil Capacity (84-24-10)
- 2.0/2.2/2.3/2.8/7.5L Eng Exhaust Leak/Noise (85-23-17)
- Approved Adhesives & Sealants For Eng/Trans/Steering (89-6T-7)
- Service PROC For Nylon Fuel Tubes & Push Connectors (85-19-20)
- Manual Steering
- Manual Trans
- Adhesives & Sealants - Availability & Usage (89-12-2)
- M/T Fluid Usage/Drivetrain Lubrication Charts (89-8-16)
- Manual Transmissions Hard To Shift Cold - REPL Fluid (88-22-8)
- Driveline Clank/Ratchet In Reverse - New Driveshaft (88-2-15)
- Transmission Fluid Leak - Smooth Mounting/New Gasket (87-25-12)
- TK 5-Speed Trans Hard Shifting:New Output Shaft (87-15-12)
- 5-SPD Trans Shift Tower Leak - New Shift Lever (87-4-18)
- Engine Oil Health Warning: Skin Contact (86-15-7)
- 5SOD Trans Lubricant Quality Correction (85-19-19)
- Approved Adhesives & Sealants For Eng/Trans/Steering (89-6T-7)
- M50D Trans Gear Whine - New Oil Level/Flow (86-11-28)
- Mechanical
- Engine Hesitation/Stall/Low Eng Temp: Diagnosis (93-24-8)
- Nylon Fuel Line Service (92-12-16)
- New Idle Air By-Pass Kit & ECA Relearn Procedure (91-7-4)
- Poor Cold Start/Idle/Run - Fuel Recommendations (91-8-13)
- Hard Start - Revised DURASPARK II Ignition Module (90-1-5)
- Adhesives & Sealants - Availability & Usage (89-12-2)
- Oil Dipstick Level Markings Unclear - Reading Marks (88-8-9)
- Revised Electric Fuel Pump Testing (87-11-15)
- 2.9/5.0/6.9L Water In Air Intake - New Air Cleaner (87-2-25)
- Fuel Stabilizer During Extended Vehicle Storage (86-13-20)
- Fuel Line Retainer Clips Part No.S (85-6-19)
- Using Oil-Leak-BLACKLITE (85-5-13)
- Fuel Odor - Liquid/Vapor Leak Diagnosis (85-1-16)
- 2.0/2.2/2.3/2.8/7.5L Eng Exhaust Leak/Noise (85-23-17)
- 2.8/3.8L Carb Eng Stumble/Stall - Heated Carb Spacer (86-25-13)
- Approved Adhesives & Sealants For Eng/Trans/Steering (89-6T-7)
- Knock Noise From Engine - Slave Cylinder Rattling (86-22-20)
- Low Fuel Pump Voltage Fuel Starvation - Loose Wires (86-11-23)
- Service PROC For Nylon Fuel Tubes & Push Connectors (85-19-20)
- Mechanical - Air
- Mechanical - Hydraulic
- Wheels - Proper Lug Torque Procedures - Service Tip (98-5A-4)
- On-Vehicle Caliper Mounted Brake Rotor Machining EQP (94-25-2)
- Rubber Brake Hose Sweating - Leak Test Procedure (91-18-9)
- Occasional Or Intermittent Brake Squeal - Normal (90-22-6)
- Engine Oil Health Warning: Skin Contact (86-15-7)
- Brake Rotors Updated Diagnosis/Service (85-9-8)
- Brake Fluid Discoloration Diagnosis (84-12-8)
- Asbestos Brake & Clutch Warnings (83-22-1)
- Occasional\Intermittent Brake Squeal - Normal (86-6-9)
- Rattle Noise From Front - New Design Caliper Pins (88-13-7)
- Rear Brake Squeal - New Brake Pads (89-20-10)
- Mirrors
- Overdrive Unit
- Paint & Coatings
- Urethane Mounted Glass Material Usage Procedure (95-12-1)
- Paint Iron Particle Removal/Acid Rain Neutralization (95-6-1)
- Primed Sheet Metal Prep Procedure & MSDS Information (94-23-4)
- Exterior Paint Comprehensive Repair Procedures (91-18-1)
- Lower Body Stone Protection Repair Tips (90-15-3)
- Treating Cosmetic Paint Damage From AIRBORN Material (89-13-3)
- Aluminum Wheels W/Coating Service Wear Information (86-9-9)
- Passive Restraints
- Latches - Door - Replacement Required (91-8-4)
- Safety Belt Tongue Cover Parts Availability (88-25-2)
- Safety Belt - Replacement Procedure After Accident (88-15-3)
- Door & Vent Windows - Excessive Efforts To Open (85-4-2)
- Front Spring Retainer Squeak Noise (85-8-25)
- Seat/Shoulder Belt General Service Information (85-2-4)
- Rear Suspension
- Seats
- Safety Belt Tongue Cover Parts Availability (88-25-2)
- Safety Belt - Replacement Procedure After Accident (88-15-3)
- Power Door Locks Inoperative - Rod Retainer Clip (88-7-1)
- Door & Vent Windows - Excessive Efforts To Open (85-4-2)
- Seat/Shoulder Belt General Service Information (85-2-4)
- Battery Drain - Electrical Component Diagnosis (84-15-9)
- Power Door Locks CONTINOUSLY Cycle/Battery Goes Low (85-23-15)
- Sleeper
- Starter
- New Idle Air By-Pass Kit & ECA Relearn Procedure (91-7-4)
- Battery Testing Procedure (91-10-10)
- No Crank - Low State Of Battery Charge (91-10-8)
- No Start/Low Battery/Fuel Pump Noise - Pump Relay (90-18-3)
- Hard Start - Revised DURASPARK II Ignition Module (90-1-5)
- Revised Electric Fuel Pump Testing (87-11-15)
- Fuel Stabilizer During Extended Vehicle Storage (86-13-20)
- Low Fuel Pump Voltage Fuel Starvation - Loose Wires (86-11-23)
- Service PROC For Nylon Fuel Tubes & Push Connectors (85-19-20)
- Steering Column
- Steering Control Systems
- Steering Gear
- Steering Linkage
- XR50 Steering Gear Input Shaft Leaks: New Shaft Seal (93-6-7)
- Steering Pull/Drift - New Service Adjusters (89-21-10)
- Steering Drift/Memory Steer - New Steering Linkage (85-10-22)
- Front Spring Retainer Squeak Noise (85-8-25)
- Approved Adhesives & Sealants For Eng/Trans/Steering (89-6T-7)
- Steering Pull/Drift New Align Adjusters (89-9T-22)
- Wheel Stud Replacement Procedure (86-11-19)
- Sun Roof/T-Top/Convertible Top
- Treating Cosmetic Paint Damage From AIRBORN Material (89-13-3)
- Manual Vent Windows - Glass Sticks To Weatherstrip (88-14-1)
- Manual Vent Windows Stuck - Pressure Sensitive Tape (88-5-2)
- Aluminum Wheels W/Coating Service Wear Information (86-9-9)
- Door & Vent Windows - Excessive Efforts To Open (85-4-2)
- Window Regulator Inoperative Or Handle Loose (85-3-1)
- Suspension Control Systems
- System
- CALIFORNIA Reformulated Gasoline - Service Tip (96-10-7)
- Engine Hesitation/Stall/Low Eng Temp: Diagnosis (93-24-8)
- EXH Gas Oxygen Sensor Silicone Sealer Contamination (93-23-6)
- Nylon Fuel Line Service (92-12-16)
- New Idle Air By-Pass Kit & ECA Relearn Procedure (91-7-4)
- No Crank - Low State Of Battery Charge (91-10-8)
- Poor Cold Start/Idle/Run - Fuel Recommendations (91-8-13)
- Electronic Control Modules - Damage From Arc Welding (91-7-5)
- No Start/Low Battery/Fuel Pump Noise - Pump Relay (90-18-3)
- Hard Start - Revised DURASPARK II Ignition Module (90-1-5)
- Emission Maintenance Warning Module - Information (89-22-8)
- TPS Service Replacement Chart (89-16-4)
- Throttle Position Sensor Screw Removal (89-14-7)
- Adhesives & Sealants - Availability & Usage (89-12-2)
- Distributor Gear Matched To Distributor At Assembly (89-6-11)
- EEC IV Eng & 2.3L/2.5L HSC CFI Map/Bap Sensor Applications Chart (89-1-12)
- Electronic Modules - Damage From Static Electricity (88-13-3)
- TFI Module/Pip Sensor New EEC-IV Testing (87-21-10)
- 2.0/2.3/2.5/3.0/3.8/5.0/5.8L Eng Short IGN Coil (87-20-18)
- CFI Fuel Injector Contamination - Replace Injector (87-17-5)
- Revised Electric Fuel Pump Testing (87-11-15)
- TFI Stall/No Start - TFI Module Diagnosis/Sealing (87-6-10)
- Fuel Line Spring Lock Coupling R & R (87-3-8)
- New Distributor Drive Gear Removal Tool (87-2-18)
- Wiring System Testing Caution - Modify Probe Tips (87-2-5)
- Aftermarket Theft Device - EEC Warnings (86-3-9)
- Fuel Stabilizer During Extended Vehicle Storage (86-13-20)
- Gas Check - Gasoline Testing Kit (86-13-21)
- TFI Eng No Start/Stall At Idle - New Ignition Module (86-11-25)
- Poor Performance - Vacuum System Diagnosis (86-9-11)
- ECM Spout Line Connector Locations (86-4-17)
- Miss/Stall/Ignition Radio Noise - Ignition Coil (86-2-8)
- TFI Ignition System Resistance Test - Tips/Caution (86-2-19)
- TFI Ignition System Weak/No Spark - Diagnostic Tips (86-2-20)
- DRIVEABILITY Concerns - Moist EEC-IV Connectors (85-25-9)
- 2.8L Eng Surge & Buck - Contaminated EGR Valve (85-19-12)
- EGR Solenoid/Vacuum Harness Contamination Caution (85-13-5)
- Map Sensor New Part Numbers/Applications (85-12-17)
- No Start/Rough Idle/Knock - Hall Effect Diagnosis (85-7-11)
- Fuel Line Retainer Clips Part No.S (85-6-19)
- EGR Valve Position Sensor Part Id Information (85-5-17)
- 2.8L Eng Distributor Octane Rod Replacement (85-2-18-S)
- Distributor Stator Assembly R & R (85-4-21)
- 2.0/2.3L Rough Idle/Run - Feedback Solenoid Gasket (85-3-6)
- 2.3L EFI W/Cast Aluminum Oil Pan - New Oil Capacity (84-24-10)
- 2.3L Eng Clunk/Hesitation/Surge - Updated Ecu (84-24-7-S)
- Coil Durability & Radio Frequency Interference (84-22-8)
- Surging/High Idle After Battery Is Disconnected (84-19-13)
- 2.0/2.2/2.3/2.8/7.5L Eng Exhaust Leak/Noise (85-23-17)
- 2.3/2.5L Eng New Map/Bap Sensor Application Table (89-1T-19)
- 2.8/3.8L Carb Eng Stumble/Stall - Heated Carb Spacer (86-25-13)
- Approved Adhesives & Sealants For Eng/Trans/Steering (89-6T-7)
- EEC-IV Test Code 53 Throttle Position Sensor Diag (85-20-11)
- Emission Light Stays On - Replace/Reset Procedure (85-21-11)
- EMW/IMS Warning Module Definition Location (89-11T-20)
- Engine Compartment Intermittent Concern Diag Process (85-17-3)
- Low Fuel Pump Voltage Fuel Starvation - Loose Wires (86-11-23)
- No Start EEC IV - E-Core Ignition Coil Damage Test (85-16-13)
- Revised EEC Power Relay Pin-Out Location (85-15-5)
- Service PROC For Nylon Fuel Tubes & Push Connectors (85-19-20)
- Throttle Position Sensor POZIDRIVE Mount Screw Info (89-7T-9)
- Towing
- Transfer Case
- 4WD Automatic HUBLOCK Information - Service Tip (95-5-18)
- 4X4 General Info, Operating Characteristics & Tips (92-1-8)
- Adhesives & Sealants - Availability & Usage (89-12-2)
- Driveline Clank/Ratchet In Reverse - New Driveshaft (88-2-15)
- A4LD Trans Leaks/Burnt Fluid/Eng Stall/Erratic Shift (87-2-15)
- Transfer Case 1350 - Oil Pump Retainer Revised (85-10-25)
- Transmission Control Systems
- Vacuum Pumps/Lines/Tanks/Water Trap
- Wheel Alignment
- Wheel Hubs
- Wheels & Tire System
- Wheels - Proper Lug Torque Procedures - Service Tip (98-5A-4)
- Tire Company Phone Numbers For Customer Assistance (98-5-2)
- Aluminum Wheels W/Coating Service Wear Information (86-9-9)
- Front Tire Wear - Rotate Tires And Check Alignment (86-24-27)
- Steering Pull/Drift New Align Adjusters (89-9T-22)
- Tire Wear - Load/Tire Inflation Information (89-5T-20)
- Wheel Stud Replacement Procedure (86-11-19)
- Window Motors & Regulators
- Urethane Mounted Glass Material Usage Procedure (95-12-1)
- "Iridescence" Or "Mottling" In Tempered Glass (93-21-1)
- Cracks At Swing-Away Spare Tire: New Assembly (88-20-11)
- Manual Vent Windows - Glass Sticks To Weatherstrip (88-14-1)
- Power Door Locks Inoperative - Rod Retainer Clip (88-7-1)
- Manual Vent Windows Stuck - Pressure Sensitive Tape (88-5-2)
- Door Glass Run/Extension Wind Noise - Foam Tape (87-10-16)
- Door & Vent Windows - Excessive Efforts To Open (85-4-2)
- Wind Noise Diagnostic/Repair Procedures (85-8-17)
- Window Regulator Inoperative Or Handle Loose (85-3-1)
- Battery Drain - Electrical Component Diagnosis (84-15-9)
- Power Door Locks CONTINOUSLY Cycle/Battery Goes Low (85-23-15)
- Revised Windshield Installation Procedures (89-6T-4)
- Wiper/Washer Systems
- Wiring System (Data Link Connectors, Pwr Dist., Grnd Dist.)
- Wiring - Wire Harness Terminal Repair Kit (99-6-3)
- Electrical - New Terminal Grease For Service (98-24-6)
- Electrical Diode Identification And Replacements (96-24-6)
- Generator Harness Connector Damage - Loose Contact (96-21-4)
- No Crank - Low State Of Battery Charge (91-10-8)
- Wire Harness Terminal & Connector Service Kit (89-19-5)
- Inaccurate Speedo Readings - Mechanical & Electronic (89-2-7)
- Wiring System Diagnosis Cautions (87-4-8)
- Engine Compartment - Use Waterproof Wire Connectors (87-2-6)
- Wiring Diagram Symbols Explanation (85-11-5)
- Wire Color Code Change (85-4-8)